| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 29 |
| Windscreen wiper does not clear the windscreen effectively | 12 |
| Registration plate lamp issues | 10 |
| Anti-lock braking system warning lamp indicates an ABS fault | 8 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 7 |
| Windscreen washer not working | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 6 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 5 |
| Registration plate issues | 5 |
| Horn not working (7.7 (a) (ii)) | 5 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 5 |
| Brakes imbalanced across an axle | 5 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 5 |
| Rear parking brake recording little or no effort | 4 |
| Brake pipe excessively corroded | 4 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
| Nearside Rear Shock absorbers has a serious fluid leak | 3 |
| Offside Rear Shock absorbers has a serious fluid leak | 3 |
| Offside Front coil spring broken |2.4.C.1a| | 3 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Offside Rear coil spring broken |2.4.C.1a| | 3 |
| Front brake excessively fluctuating | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Battery insecure |1.9.1| | 3 |
| Horn not working (7.7 (a)) | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Rear brake disc in such a condition that it is seriously weakened | 3 |
| Brake hose excessively deteriorated | 2 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 2 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Nearside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Obligatory mirror insecure |8.1.1| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| rear parking |secondary| brakes imbalanced | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 2 |
| Nearside Front coil spring broken |2.4.C.1a| | 2 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Rear All direction indicators incorrect colour (4.4.3 (a)) | 2 |
| Offside Rear All direction indicators incorrect colour (4.4.3 (a)) | 2 |
| Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Fuel cap/sealing device missing |7.2.4a| | 2 |
| Nearside Headlamp insecure |1.7.3| | 2 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Rear coil spring broken |2.4.C.1a| | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 2 |
| Offside Front Obligatory mirror missing |8.1.1| | 2 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Exhaust has a major leak of exhaust gases rear box (6.1.2 (a)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Central Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Offside Rear Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Central Rear Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Nearside Front Suspension component insecure and impairing directional stability Coil spring top mount and bearing damaged. (5.3.3 (a) (ii)) | 1 |
| Nearside Rear Passengers seat backrest cannot be secured in the upright position. (6.2.6 (a) (i)) | 1 |
| Central Front Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Front Brake disc significantly and obviously worn Both (1.1.14 (a) (i)) | 1 |
| Front Headlamps matched pair incorrect colour (4.1.4 (a)) | 1 |
| Offside Outer Power steering pump leaking leaking through the steering rack gaitor (2.1.5 (a)) | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Stop lamp|s| not working nearside rear |4.3.1 |a| |ii|| | 1 |
| Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt offside front upper |5.3.4 |b| |ii|| | 1 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front Exhaust has a major leak of exhaust gases pipe |6.1.2 |a|| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |8.1.1 |a|| | 1 |
| Exhaust emissions likely to be affected by an exhaust leak |8.2.1.1 |b|| | 1 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Boot lid cannot be secured in the closed position |6.2.1 |e|| | 1 |
| Rear brake binding | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Steering column has excessive movement up and down |2.2.2 |a|| | 1 |
| Emissions not tested |8.2.1.2 |d|| | 1 |
| Steering rack has excessive free play detected at the steering wheel (steering rack fitted) both rack ends (2.3 (a) (i)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Offside Rear Hydraulic brake cylinder leaking hydraulic fluid (1.1.16 (b) (i)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Rear Suspension component pin or bush excessively worn axle bush |5.3.4 |a| |i|| | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions unable to be completed lambda too high (8.2.1.2 (d)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Brake fluid contaminated |1.8 |a|| | 1 |
| Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Horn not working |1.6.2a| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Offside Rear Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn back bush (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn back bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Front Exhaust has a major leak of exhaust gases front flexi (6.1.2 (a)) | 1 |
| Exhaust system insecure centre clamp bolt missing (6.1.2 (a)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Sub-frame insecurely attached Bolt loose (5.3.3 (a) (i)) | 1 |
| Front Engine mounting bracket damaged or deteriorated resulting in excessive movement (6.1.8 (a) (i)) | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Trailer electrical socket |13 pin| not operating the trailer lamps as intended |1.9.4| | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Sub-frame strengthening plate or fastening insecure bolt missing (6.1.1 (b) (i)) | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Horn not working Turns volume up instead |1.6.2a| | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases Front Flexy pipe (6.1.2 (a)) | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Front Sub-frame attachment bracket/mounting bolt missing |2.4.G.1| | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Headlamp aim not tested (4.1.2 (b)) | 1 |
| Nearside Front Drive shaft joint so worn it is likely to fail (6.1.7 (c) (ii)) | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear Lower Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Nearside Front Inner Steering rack has excessive free play detected at the steering wheel (steering rack fitted) tie rod arm joint (2.3 (a) (i)) | 1 |
| Offside Front Inner Steering rack has excessive free play detected at the steering wheel (steering rack fitted) tie rod arm joint (2.3 (a) (i)) | 1 |
| Front Exhaust has a major leak of exhaust gases flexi joint |6.1.2 |a|| | 1 |
| Rear Direction indicator incorrect colour both |1.4.A.2f| | 1 |
| Front Headlamps matched pair are not the same colour |1.7.6| | 1 |
| Nearside Front Road wheel cracked |4.2.A.1a| | 1 |
| Nearside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Fuel cap/sealing device ineffective |6.1.3 |b| |i|| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Emissions not tested due to developing misfire |8.2.1.2 |d|| | 1 |
| Direction indicator incorrect colour Both rear. (4.4.3 (a)) | 1 |
| Nearside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Offside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Nearside Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Offside Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Nearside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Central Rear Seat belt not functioning as intended |7.1.2 |c|| | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |