| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 125 |
| Headlamp aim out of alignment | 87 |
| Registration plate lamp issues | 64 |
| Brake pipe excessively corroded | 43 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 39 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 30 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 30 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 26 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 25 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 23 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 20 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 20 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 19 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 18 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 18 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 18 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 16 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 16 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 16 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 16 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 14 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 14 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 14 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 13 |
| Windscreen washer not working | 13 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 13 |
| Registration plate issues | 12 |
| Front brake disc in such a condition that it is seriously weakened | 11 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 11 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 10 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 10 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 10 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 9 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 9 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 9 |
| Parking brake: efficiency below requirements |3.7.B.7| | 9 |
| Brakes imbalanced across an axle | 9 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 9 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 9 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 8 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 8 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 7 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 7 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 7 |
| Nearside Rear Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 7 |
| Offside Rear Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 7 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 6 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 6 |
| Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 6 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 6 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 6 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 6 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 6 |
| Rear parking brake recording little or no effort | 6 |
| Emissions unable to be completed (8.2.1.2 (d)) | 5 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 5 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 5 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 5 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 5 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 5 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 5 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 5 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 5 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 4 |
| Brake performance not tested (1.2.1 (g)) | 4 |
| Windscreen has damage | 4 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 4 |
| Rear brake disc in such a condition that it is seriously weakened | 4 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 4 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 4 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 4 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Offside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 4 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 4 |
| Front brake application uneven | 4 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 4 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 4 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 4 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Battery insecure |1.9.1| | 3 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Nearside Rear Shock absorbers has a serious fluid leak | 3 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 3 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Horn not working (7.7 (a)) | 3 |
| Offside Front front brake binding |3.7.B.1| | 3 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Nearside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside front brake binding |3.7.B.1| | 3 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 3 |
| Nearside Rear Valve stem seriously damaged (5.2.3 (j)) | 3 |
| Nearside front brake binding |3.7.B.1| | 3 |
| Nearside Front Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Nearside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 3 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Nearside Rear Lower Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 3 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 3 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Nearside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |