| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 11 |
| Headlamp aim out of alignment | 9 |
| Brakes imbalanced across an axle | 9 |
| Brake pipe excessively corroded | 9 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 8 |
| Nearside Front coil spring broken |2.4.C.1a| | 5 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 5 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 5 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 4 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 4 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 3 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Offside Rear coil spring broken |2.4.C.1a| | 2 |
| Registration plate issues | 2 |
| Offside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 2 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 2 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Offside Front Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Rear Exhaust has a major leak of exhaust gases box |6.1.2 |a|| | 1 |
| Windscreen wiper blade insecure | 1 |
| Front Brake disc significantly and obviously worn both (1.1.14 (a) (i)) | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Front Sub-frame pin or bush excessively worn both rear bushes (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint drop link |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint drop link |2.4.G.2| | 1 |
| Rear brake application uneven | 1 |
| Offside Front Suspension arm ball joint likely to become detached |5.3.4 |a| |ii|| | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Rear Service brake has no recorded effort at a wheel |1.2.1 |a| |ii|| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Rear All direction indicators incorrect colour |4.4.3 |a|| | 1 |
| Offside Rear All direction indicators incorrect colour |4.4.3 |a|| | 1 |
| Offside Rear Brake performance unable to be tested brake pipe burst (1.2.1 (g)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak exhaust rear silencer broken and center section at flexible pipe blowing excessively (8.2.1.1 (b)) | 1 |
| Windscreen washer not working | 1 |
| Brake lever has insufficient reserve travel hand brake (1.1.2 (a)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Front Lower Suspension arm ball joint likely to become detached |5.3.4 |a| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases middle section (6.1.2 (a)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Central Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Central Exhaust has a major leak of exhaust gases cat (6.1.2 (a)) | 1 |
| Central Rear Exhaust has a major leak of exhaust gases back box (6.1.2 (a)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Fuel tank exhaust shield missing where fitted as original equipment creating a risk of fire (6.1.3 (e)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak silencer (8.2.1.1 (b)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn wishbone rear bush (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn wishbone rear bush (5.3.4 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front brake excessively fluctuating | 1 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Rear Direction indicator incorrect colour white light (4.4.3 (a)) | 1 |
| Offside Rear Direction indicator incorrect colour white light (4.4.3 (a)) | 1 |
| Nearside Front Direction indicator incorrect colour white light (4.4.3 (a)) | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Central Front Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Rear Exhaust silencer likely to become detached (8.1.1 (b) (ii)) | 1 |
| Emissions not tested exhaust is full of holes due to corrosion (8.2.2.2 (e)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Sub-frame attachment rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Inner Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Inner Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases centre and rear join (6.1.2 (a)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Registration plate lamp issues | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Offside Rear Parking (secondary brake) on a single line braking system grabbing severely (1.3.1 (c)) | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |