| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 32 |
| Windscreen wiper does not clear the windscreen effectively | 32 |
| Brake pipe excessively corroded | 20 |
| Registration plate lamp issues | 11 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 10 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 8 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 8 |
| Nearside Front coil spring broken |2.4.C.1a| | 8 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 6 |
| Offside Front coil spring broken |2.4.C.1a| | 5 |
| Brakes imbalanced across an axle | 5 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 5 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 5 |
| Registration plate issues | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 4 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 4 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Nearside Rear Stop lamp not working |1.2.1b| | 4 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
| Nearside Rear coil spring broken |2.4.C.1a| | 4 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 3 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 3 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 3 |
| Horn not working (7.7 (a)) | 3 |
| Offside Front Sub-frame pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 3 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Nearside Position lamp not working |4.2.1 |a|| | 2 |
| Offside Front Position lamp not working |4.2.1 |a|| | 2 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Rear Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 2 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Brake hose excessively deteriorated | 2 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Nearside Front Headlamp insecure (4.1.1 (c)) | 2 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Steering rack insecure |2.2.B.1a| | 1 |
| Offside Front Lower Sub-frame pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Central Rear Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Offside Front Sub-frame pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Headlamps matched pair incorrect colour both front (4.1.4 (a)) | 1 |
| Nearside Front Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases blow at joint of cat (6.1.2 (a)) | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Sub-frame pin or bush excessively worn rear bush |5.3.4 |a| |i|| | 1 |
| Offside Front Sub-frame pin or bush excessively worn rear bush |5.3.4 |a| |i|| | 1 |
| Nearside Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Central Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Front Sub-frame pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Lower Steering linkage ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Exhaust emissions - engine idle speed too high (8.2.1.2 (e)) | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Sub-frame pin or bush excessively worn subframe bushes (5.3.4 (a) (i)) | 1 |
| Offside Front Sub-frame pin or bush excessively worn subframe bushes (5.3.4 (a) (i)) | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Outer Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Drivers seat insecure (6.2.5 (a) (ii)) | 1 |
| Central Front Bumper likely to become detached (6.1.4 (a) (ii)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases Tailbox not adequately fitted. (6.1.2 (a)) | 1 |
| Front Windscreen in an unacceptable condition (3.2 (c) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn wish bone bush (5.3.4 (a) (i)) | 1 |
| Nearside Headlamp levelling device cannot be operated from the drivers seat (4.1.5 (b)) | 1 |
| Exhaust system not adequately supported between back box and centre section , leaking gases |7.1.1| | 1 |
| Drivers view of the road through the swept area of the windscreen materially affected by an obstruction Sunvisor (3.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Offside Rear coil spring cracked |2.4.C.1a| | 1 |
| Offside Front Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Offside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Windscreen wiper not working |3.4 |a|| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Front Brake disc significantly and obviously worn and severe fluctuation. (1.1.14 (a) (i)) | 1 |
| Nearside Front Sub-frame insecurely attached subframe moving at mounting area needs further examination. (5.3.3 (a) (i)) | 1 |
| Power steering pump drive system defective |2.3.6| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Anti-roll bar ball joint likely to become detached |5.3.4 |a| |ii|| | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Suspension arm pin or bush likely to become detached |5.3.4 |a| |ii|| | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Rear Service brake imbalanced across an axle (1.2.1 (b) (i)) | 1 |
| Nearside Side repeater lens defective such that the emitted light is adversely affected (4.4.1 (b) (ii)) | 1 |
| Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Outer Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Windscreen wiper blade missing (3.4 (b) (ii)) | 1 |
| Offside Front Wheel bearing so rough it is likely to overheat or break up |5.1.3 |b| |ii|| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Nearside Front Hydraulic brake cylinder leaking hydraulic fluid |1.1.16 |b| |i|| | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Front Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt drop-link |2.4.G.2| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases SILENCER CORRODED ADRIFT FROM MID SECTION (6.1.2 (a)) | 1 |
| Offside Front Drivers view of the road through the swept area of the windscreen materially affected by an obstruction visor not securing in upright position (3.1 (a) (ii)) | 1 |
| Front Sub-frame attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Offside Front Brake hose damaged and likely to fail not secured properly (1.1.12 (a)) | 1 |
| Offside Front Brake hose damaged and likely to fail brake hose not cliped |1.1.12 |a|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Rear brake binding | 1 |
| Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Rear brake application uneven | 1 |
| Offside Front Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` sun visor cannot be stowed off scereen |8.3.1b| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Front Inner Brake disc significantly and obviously worn both sides (1.1.14 (a) (i)) | 1 |
| Nearside Front Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Front Sub-frame has excessive play in a pin/bush o/s rear most bush collapsed |2.4.G.2| | 1 |
| Offside Front Suspension arm pin or bush likely to become detached rear most bush separated (5.3.4 (a) (ii)) | 1 |