Most common failures | No# failures |
---|
Windscreen wiper does not clear the windscreen effectively | 55 |
Headlamp aim out of alignment | 42 |
Brake pipe excessively corroded | 41 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 17 |
Registration plate lamp issues | 16 |
Nearside Front coil spring broken |2.4.C.1a| | 16 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 14 |
Offside Front coil spring broken |2.4.C.1a| | 13 |
Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 12 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 11 |
Anti-lock braking system warning lamp indicates an ABS fault | 9 |
Brakes imbalanced across an axle | 9 |
Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 8 |
Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 8 |
Rear brake disc in such a condition that it is seriously weakened | 8 |
Offside Stop lamp not working |1.2.1b| | 7 |
Offside Front position lamp|s| not working |1.1.A.3b| | 7 |
Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 7 |
Parking brake lever has no reserve travel |3.1.6b| | 7 |
Front brake disc in such a condition that it is seriously weakened | 7 |
Nearside Stop lamp not working |1.2.1b| | 6 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 6 |
Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 6 |
Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 6 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 6 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 6 |
Parking brake: efficiency below requirements |3.7.B.7| | 6 |
Rear brake binding | 6 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 6 |
Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 5 |
Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 5 |
Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 5 |
Nearside Rear coil spring broken |2.4.C.1a| | 5 |
Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 5 |
Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 5 |
Offside Front Position lamp not working |4.2.1 |a|| | 5 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 5 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 5 |
Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 5 |
Horn not working (7.7 (a) (ii)) | 4 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
Offside Rear Stop lamp not working |1.2.1b| | 4 |
Offside Parking brake inoperative on one side (1.4.1 (a)) | 4 |
Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 4 |
Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 4 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 3 |
Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
Registration plate issues | 3 |
Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Nearside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 3 |
Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 3 |
Nearside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 3 |
Horn not working (7.7 (a)) | 3 |
Nearside Front Position lamp not working |4.2.1 |a|| | 3 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
Offside Rear coil spring broken |2.4.C.1a| | 3 |
Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 2 |
Battery insecure |1.9.1| | 2 |
Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 2 |
Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 2 |
Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
Front brake application uneven | 2 |
Offside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 2 |
Rear parking brake recording little or no effort | 2 |
Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
Rear brake application uneven | 2 |
Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 2 |
Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
Offside Front Sub-frame pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
Offside Front Inner Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 2 |
Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 2 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 2 |
Emissions not tested |7.3.A.1| | 2 |
Nearside Front coil spring incomplete |2.4.C.1a| | 2 |
Front brake excessively fluctuating | 2 |
Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 2 |
Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` sun visor cannot be held in the upright position |8.3.1b| | 1 |
Offside Front Suspension arm pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
Front Sub-frame pin or bush excessively worn both bushes marked with yellow chalk (5.3.4 (a) (i)) | 1 |
Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
Offside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
Offside Rear Shock absorbers has a serious fluid leak | 1 |
Central Front Bumper insecure |6.1.4 |a| |i|| | 1 |
Drivers view of the road through the swept area of the windscreen materially affected by an obstruction (3.1 (a) (ii)) | 1 |
Direction indicator incorrect colour both rear bulbs discolored (4.4.3 (a)) | 1 |
Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Offside Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Lower Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Rear Exhaust system insecure |6.1.2 |a|| | 1 |
Emissions not tested |8.2.1.2 |d|| | 1 |
Central Rear Stop lamp not working |1.2.1b| | 1 |
Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Lower Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
Nearside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
Offside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
Rear Direction indicator incorrect colour both |1.4.A.2f| | 1 |
Oil leaking excessively from engine sump (8.4.1 (a) (i)) | 1 |
Offside Rear Service brake excessively binding unable to check wheel bearings (1.2.1 (f)) | 1 |
Oil leaking excessively from engine sump heavily corroded and leaking (8.4.1 (a) (i)) | 1 |
Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Emissions not tested due to excessive leaks at exhaust system |8.2.1.2 |d|| | 1 |
Brake lever has insufficient reserve travel handbrake lever |1.1.2 |a|| | 1 |
Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Nearside Rear rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
Nearside Parking brake inoperative on one side 0 kg no lockout (1.4.1 (a)) | 1 |
Brake lever has insufficient reserve travel handbrake (1.1.2 (a)) | 1 |
Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Windscreen washer not working | 1 |
Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
Nearside Headlamp insecure bolt missing (4.1.1 (c)) | 1 |
Rear Exhaust emissions likely to be affected by an exhaust leak silencer (8.2.2.1 (b)) | 1 |
Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Central Exhaust has a major leak of exhaust gases Middle Pipe (6.1.2 (a)) | 1 |
Emissions not tested Due to exhaust leak (8.2.1.2 (d)) | 1 |
Front Coil spring fractured or broken both front coil springs broken (5.3.1 (b) (i)) | 1 |
Nearside Front Suspension component pin or bush excessively worn lower sus arm rear bush split and dropped in outer casing (5.3.4 (a) (i)) | 1 |
Emissions not tested due to exhaust broken and leaking gasses (8.2.1.2 (d)) | 1 |
Exhaust has a major leak of exhaust gases front flexible coupling not attached due to flange corroded away from catalitic converter (6.1.2 (a)) | 1 |
Nearside Inner Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Offside Inner Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Service brake: efficiency below requirements |3.7.B.7| | 1 |
Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
Offside Front Lower Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Central Exhaust has a major leak of exhaust gases TO TAIL SECTION (6.1.2 (a)) | 1 |
Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt Insecure |6.1.7 |g| |ii|| | 1 |
Emissions not tested exhaust system blowing could not get an accurate reading (8.2.1.2 (d)) | 1 |
Exhaust has a major leak of exhaust gases back box (6.1.2 (a)) | 1 |
Nearside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
Offside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
Offside Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |
Offside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
Central Rear Seat belt not functioning as intended |7.1.2 |c|| | 1 |
Central Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Nearside Front Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
Central Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Front suspension has excessive play in a lower suspension ball joint bttm ball joint |2.5.B.1a| | 1 |
Nearside Front Radius arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Lower Radius arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
Emissions not tested (8.2.1.2 (d)) | 1 |
Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Emissions not tested Major exhaust blow (8.2.1.2 (d)) | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front coil spring fractured |2.4.C.1a| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Front Exhaust has a major leak of exhaust gases joint at cat (6.1.2 (a)) | 1 |
Nearside Front Lower Suspension arm pin or bush excessively worn Rear Bush (5.3.4 (a) (i)) | 1 |
Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Brake hose inappropriately repaired Insecure |3.6.A.3| | 1 |
Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Nearside Front Headlamp lens seriously defective cloudy (4.1.1 (b) (ii)) | 1 |
Offside Front Headlamp lens seriously defective cloudy (4.1.1 (b) (ii)) | 1 |
Nearside Front Front position lamp|s| obviously incorrectly positioned |1.1.A.3a| | 1 |
Nearside Front Suspension arm has excessive play in a pin/bush rearmost bush |2.4.G.2| | 1 |
Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
Offside Driver`s view of the road through the swept area of the windscreen materially affected by an obstruction |3.1 |a| |ii|| | 1 |
Exhaust emissions likely to be affected by an exhaust leak At front pipe after cat |8.2.1.1 |b|| | 1 |
Offside Front Lower Suspension component ball joint excessively worn Ball joint |5.3.4 |a| |i|| | 1 |
Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front Suspension arm pin or bush excessively worn rear bush |5.3.4 |a| |i|| | 1 |
Offside Front Suspension arm pin or bush excessively worn rear bush |5.3.4 |a| |i|| | 1 |
Nearside Front Anti-roll bar linkage has excessive play in a ball joint droplink |2.4.G.2| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Offside Rear brake caliper has restricted free movement brakes binding on |3.5.1k| | 1 |
Rear Other passenger door cannot be opened from outside the vehicle boot lid (6.2.3 (a)) | 1 |
Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Nearside Front Suspension arm pin or bush excessively worn Rear bush. (5.3.4 (a) (i)) | 1 |
Offside Front Suspension arm pin or bush excessively worn Rear bush. (5.3.4 (a) (i)) | 1 |
Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Nearside Front Lower Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
Exhaust has a major leak of exhaust gases middile pipe (6.1.2 (a)) | 1 |
Offside Front Lower Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
Offside Front Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction Sun Visor Cant Be Secured (3.1 (a) (ii)) | 1 |
Front coil spring broken both |2.4.C.1a| | 1 |
Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Driver`s airbag obviously defective |5.4.1| | 1 |
Supplementary restraint system warning lamp indicates a fault Airbag warning lamp continuously flashes. |7.1.6 |a|| | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
Offside Front Sub-frame pin or bush excessively worn Rearmost bush worn (5.3.4 (a) (i)) | 1 |
Offside Rear Service brake excessively binding 71kg bind (1.2.1 (f)) | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Driver`s view of the road through the swept area of the windscreen materially affected by an obstruction sat nav in zone A |3.1 |a| |ii|| | 1 |
Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Nearside Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |
Brake lever has insufficient reserve travel |1.1.2 |a|| | 1 |
Nearside Rear Seat belt retracting mechanism defective passenger |5.2.5b| | 1 |
Nearside Front Headlamp insecure |1.7.3| | 1 |
Nearside Front Headlamp aim not tested |1.8.A.1c| | 1 |
Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Front Brake hose excessively twisted |1.1.12 |b| |ii|| | 1 |
Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Rear Inner Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
Front Suspension arm ball joint excessively worn both (5.3.4 (a) (i)) | 1 |
Sub-frame pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |