| Most common failures | No# failures |
|---|
| Registration plate issues | 18 |
| Brake pipe excessively corroded | 12 |
| Headlamp aim out of alignment | 9 |
| Registration plate lamp issues | 9 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 8 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 7 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 7 |
| Horn not working (7.7 (a)) | 7 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 6 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 6 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 5 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Brakes imbalanced across an axle | 4 |
| Windscreen washer not working | 4 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 4 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 4 |
| Rear fog lamp emits a light other than red |1.3.2e| | 3 |
| Offside Rear Shock absorbers has a serious fluid leak | 3 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Offside Rear fog lamp missing |1.3.2a| | 3 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 3 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Rear fog lamp missing |4.5.1 |a| |ii|| | 2 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Rear Shock absorbers has a serious fluid leak | 2 |
| Nearside Rear Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Horn not working |1.6.2a| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Emissions unable to be completed (8.2.1.2 (d)) | 2 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
| Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 2 |
| Offside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 2 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Exhaust has a major leak of exhaust gases Both flexi pipes (6.1.2 (a)) | 1 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Supplementary restraint system warning lamp indicates a fault Airbag light flashing (7.1.6 (a)) | 1 |
| Offside Rear Brake hose excessively twisted fouling ARB link (1.1.12 (b) (ii)) | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Rear Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Nearside Rear Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Rear Sub-frame pin or bush excessively worn nearside front mounting bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction (3.1 (a) (ii)) | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear arm (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear arm (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis link bar (5.3.6 (a) (i)) | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis link bar (5.3.6 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Battery insecure |1.9.1| | 1 |
| Rear brake binding | 1 |
| Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Position lamp not working all (4.2.1 (a) (ii)) | 1 |
| Headlamp not working on dipped beam both (4.1.1 (a) (ii)) | 1 |
| Headlamp not working on main beam both (4.1.1 (a) (ii)) | 1 |
| Offside Steering linkage ball joint modification unsafe split pin missing (2.1.3 (f) (i)) | 1 |
| Nearside Steering linkage ball joint ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Nearside Front Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Offside Front Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Nearside Front Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Brake performance not tested fluid leak from ABS pump area (1.2.1 (g)) | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Parking brake lever missing hydro handbrake fitted only and will not hold on hill (1.1.6 (d)) | 1 |
| Parking brake lever ratchet not holding correctly (1.1.6 (a)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Front brake excessively fluctuating | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Offside Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Offside Front Power steering component leaking (2.1.5 (a)) | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint inner joint |2.4.G.2| | 1 |
| Suspension component mounting prescribed area is excessively corroded offside rear inner sill corroded and holed |2.4.A.3| | 1 |
| Front Position lamp not working x2 (4.2.1 (a) (ii)) | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Offside Front Suspension arm ball joint excessively worn Rear (5.3.4 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases emissions not tested because of this (6.1.2 (a)) | 1 |
| Nearside Rear Stop lamp|s| not working loose connection |4.3.1 |a| |ii|| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Steering wheel spokes loose (2.2.1 (c) (i)) | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner arch (5.3.6 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn rear (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn rear (5.3.4 (a) (i)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Rear Service brake excessively binding N/S and O/S brakes binding (1.2.1 (f)) | 1 |
| Steering wheel has movement relative to the column indicating looseness (2.2.1 (a) (i)) | 1 |
| Nearside Rear Suspension arm ball joint dust cover no longer prevents the ingress of dirt Track arm (5.3.4 (b) (ii)) | 1 |
| Offside Rear Suspension arm ball joint dust cover no longer prevents the ingress of dirt Track arm (5.3.4 (b) (ii)) | 1 |
| Emissions not tested Due to vehicle temp (8.2.1.2 (d)) | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Front Inner Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Nearside Rear Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting SILL (6.2.2 (d) (i)) | 1 |
| Offside Rear Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting SILL (6.2.2 (d) (i)) | 1 |
| Offside Front Lower Floor excessively deteriorated FOOTWELL (6.2.4 (a) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage missing (5.3.3 (a) (ii)) | 1 |
| Offside Front Anti-roll bar linkage missing (5.3.3 (a) (ii)) | 1 |
| Exhaust emissions - engine idle speed too high (8.2.1.2 (e)) | 1 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.2.1 (a)) | 1 |
| Nearside Rear Upper Suspension arm fractured snapped (5.3.3 (b) (ii)) | 1 |
| Brake performance not tested suspension arm snapped unable to test (1.2.1 (g)) | 1 |
| Offside Front Drivers airbag missing (7.1.5 (a)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Lower Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Rear Lower Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Front Lower Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Headlamp not working on main beam Nearside (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Vehicle structure inadequately repaired such that structural rigidity is significantly reduced not continues welding (6.1.1 (d) (i)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill inner and outer (6.1.1 (c) (i)) | 1 |
| Nearside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Rear Brake pipe likely to become detached or damaged (1.1.11 (d) (ii)) | 1 |
| Offside Rear Brake pipe leaking on an air braking system (1.1.11 (b) (i)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill (5.3.6 (a) (i)) | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated lever insecure (1.1.6 (d)) | 1 |
| Headlamp aim projected beam image is obviously incorrect both (4.1.2 (c)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Offside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Nearside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings both rear outter sils & o/s/r inner sil |under car| |6.1.B.2| | 1 |
| Rear fog lamp has less than 50% of the light sources illuminating |1.3.2b| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Central Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner and outer seal (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced n/s/f inner sill, n/s/r outer sill and o/s/r outer sill (marked with yellow marker) (6.1.1 (c) (i)) | 1 |
| Front Lower Suspension arm pin or bush excessively worn both sides (5.3.4 (a) (i)) | 1 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |