| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 10 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Front Brake pipe leaking |3.6.A.1| | 2 |
| Brake pipe excessively corroded | 2 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Windscreen has damage | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Offside Front Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Centre Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Offside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Upper Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
| Offside Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside Front Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Offside Front Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.2| | 1 |
| Offside Rear Body has a projection caused by damage |6.1.C.1| | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |