| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 45 |
| Headlamp aim out of alignment | 35 |
| Brake pipe excessively corroded | 19 |
| Registration plate lamp issues | 13 |
| Parking brake: efficiency below requirements |3.7.B.7| | 11 |
| Rear brake binding | 11 |
| Anti-lock braking system warning lamp indicates an ABS fault | 8 |
| Parking brake lever has no reserve travel |3.1.6b| | 7 |
| Rear brake disc in such a condition that it is seriously weakened | 7 |
| Registration plate issues | 6 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Windscreen has damage | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Brakes imbalanced across an axle | 3 |
| Centre Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Front brake disc in such a condition that it is seriously weakened | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Nearside Rear Shock absorbers has a serious fluid leak | 3 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 2 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Rear brake application uneven | 2 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear rear brake excessively fluctuating |3.7.B.3| | 2 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
| Front brake excessively fluctuating | 2 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Windscreen wiper blade insecure | 2 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Offside front brake juddering severely |3.7.A.2b| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Rear Parking brake inoperative on one side binding |1.4.1 |a|| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp aim not tested both front |1.8.A.1c| | 1 |
| Headlamp cleaning device inoperative both front |1.7.2| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Centre Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Headlamp cleaning device obviously defective |1.7.2| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner wheel arch |6.1.B.2| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Centre Rear Upper Stop lamp not working |1.2.1b| | 1 |
| Windscreen washer not working | 1 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn Trailing arm, axle bush |5.3.4 |a| |i|| | 1 |
| Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Obligatory mirror insecure |8.1.1| | 1 |
| Nearside Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
| Nearside Rear Headlamp levelling device inoperative |1.7.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Front Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Offside Front brake disc excessively scored |3.5.1h| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Lower Exhaust has a major leak of exhaust gases back silencer to center pipe |7.1.2| | 1 |
| Power steering fluid level below minimum |2.3.1| | 1 |
| Nearside Front Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Offside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Offside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
| Parking brake inoperative on one side bothsides |1.4.1 |a|| | 1 |
| Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected rear both sides |5.3.6 |a| |ii|| | 1 |
| Offside Rear Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected under sill |5.3.6 |a| |ii|| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Nearside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits exhaust blowing |7.3.D.3| | 1 |
| Exhaust has a major leak of exhaust gases tail box to inter pipe |7.1.2| | 1 |
| Centre Front Exhaust has a major leak of exhaust gases flange |7.1.2| | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Central Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded inner cill |2.4.A.3| | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area is excessively corroded cill |2.4.A.3| | 1 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area is excessively corroded cill |2.4.A.3| | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area is excessively corroded cill |2.4.A.3| | 1 |
| Offside Rear Outer Suspension component mounting prescribed area is excessively corroded cill |2.4.A.3| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Brake hose excessively deteriorated | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Offside Front Macpherson strut insecure |2.4.G.1| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Lower sill has hole caused by corrosion within rear axel suspension mount. (5.3.6 (a) (i)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Lower sill has hole caused by corrosion within rear axel suspension mount. (5.3.6 (a) (i)) | 1 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Rear Exhaust silencer insecure (8.1.1 (b) (i)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases back box joint to centre pipe joint heavily corroded and pipe has separated from joint (6.1.2 (a)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak lambda high (8.2.1.1 (b)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Offside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Headlamp has a product on the lens so that the light output is severely reduced both sides (4.1.4 (b)) | 1 |
| Offside Rear Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Offside Rear Suspension component insecurely attached sensor (5.3.3 (a) (i)) | 1 |
| Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Headlamp aim projected beam image is obviously incorrect both sides (4.1.2 (c)) | 1 |