| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 71 |
| Windscreen wiper does not clear the windscreen effectively | 61 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 38 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 37 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 32 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 27 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 27 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 26 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 23 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 21 |
| Registration plate lamp issues | 21 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 21 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 19 |
| Windscreen washer not working | 19 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 17 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 17 |
| Brakes imbalanced across an axle | 14 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 14 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 13 |
| Offside Rear Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 13 |
| Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 13 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 12 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 12 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 12 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 11 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 11 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 11 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 11 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 11 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 9 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 9 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 9 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 9 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 9 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 9 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 9 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 9 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 9 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 8 |
| Nearside Rear Shock absorbers has a serious fluid leak | 8 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 8 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 8 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 8 |
| Registration plate issues | 8 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 8 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 7 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 7 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 7 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 7 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 7 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 7 |
| Offside Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 7 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 7 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 7 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 6 |
| Nearside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 6 |
| Offside Rear Shock absorbers has a serious fluid leak | 6 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 6 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 6 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 6 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 6 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 6 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 6 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 6 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 6 |
| Offside Rear fog lamp missing (4.5.1 (a) (ii)) | 5 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 5 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 5 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Steering rack has excessive free play detected at the steering wheel (steering rack fitted) (2.3 (a) (i)) | 5 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 5 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 5 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 5 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 5 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 5 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 5 |
| Offside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 5 |
| Emissions unable to be completed (8.2.1.2 (d)) | 5 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 5 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 5 |
| Offside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 4 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 4 |
| Horn not working (7.7 (a)) | 4 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 4 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 4 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 4 |
| Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 4 |
| Offside Rear Headlamp levelling device inoperative (4.1.5 (a)) | 4 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 4 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 4 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 4 |
| Rear fog lamp switch missing (4.5.3 (a)) | 3 |
| Spare wheel insecure in carrier (6.1.5 (b) (i)) | 3 |
| Offside Rear Rear fog lamp missing (4.5.1 (a) (ii)) | 3 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Rear Headlamp levelling device inoperative (4.1.5 (a)) | 3 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 3 |
| Front brake disc in such a condition that it is seriously weakened | 3 |
| Rear brake disc in such a condition that it is seriously weakened | 3 |
| Anti-lock braking system warning lamp does not illuminate (1.6 (a)) | 3 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt split (6.1.7 (g) (ii)) | 3 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 3 |
| Offside Front Road wheel fixing missing (5.2.1 (a) (i)) | 3 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 3 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 3 |
| Brake performance unable to be tested (1.2.1 (g)) | 3 |
| Rear fog lamp switch missing (4.5.3 (a) (ii)) | 2 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt Split (5.3.4 (b) (ii)) | 2 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 2 |
| Nearside Front Anti-roll bar ball joint excessively worn drop link (5.3.4 (a) (i)) | 2 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Headlamp aim not tested (4.1.2 (b)) | 2 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Nearside Front Lower Suspension arm pin or bush excessively worn front bush (5.3.4 (a) (i)) | 2 |
| Spare wheel carrier insecure (6.1.5 (a)) | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Nearside Rear Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 2 |
| Rear fog lamp tell-tale missing (4.9.1 (a) (ii)) | 2 |
| Brake performance not tested (1.2.1 (g)) | 2 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 2 |
| Front Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i)) | 2 |
| Nearside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 2 |
| Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Nearside Front Inner Prop shaft joint constant velocity boot no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Nearside Rear Outer Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Rear Shock absorbers insecurely attached (5.3.2 (a) (i)) | 2 |
| Offside Rear fog lamp light intensity significantly reduced (4.5.4 (a)) | 2 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 2 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Offside Rear Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Rear Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Rear Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 2 |
| Nearside Rear Wheel bearing play so excessive that directional control is impaired (5.1.3 (a) (ii)) | 2 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Rear fog lamp switch not able to be operated from the normal driving position (4.5.3 (a)) | 2 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |