| Most common failures | No# failures |
|---|
| Registration plate issues | 24 |
| Windscreen wiper does not clear the windscreen effectively | 21 |
| Brake pipe excessively corroded | 19 |
| Headlamp aim out of alignment | 16 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 10 |
| Registration plate lamp issues | 9 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 8 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 8 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 8 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 7 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 6 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 6 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 5 |
| Windscreen washer not working | 5 |
| Windscreen has damage | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 5 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 4 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 4 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 3 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Rear brake binding | 3 |
| Emissions not tested (8.2.1.2 (d)) | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Rear brake disc in such a condition that it is seriously weakened | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 3 |
| Brakes imbalanced across an axle | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Nearside Front Inner Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Brake performance not tested (1.2.1 (g)) | 2 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Rear fog lamp switch missing |1.3.1a| | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Horn not working |1.6.2a| | 2 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 2 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front Road wheel fixing missing (5.2.1 (a) (i)) | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength marked with white chalk (5.3.6 (a) (i)) | 1 |
| Brake disc significantly and obviously worn both fronts on inner faces (1.1.14 (a) (i)) | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn front (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength marked with white chalk (5.3.6 (a) (i)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Rear fog lamp switch missing not fitted (4.5.3 (a)) | 1 |
| Nearside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Inner Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
| Offside Rear Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Subframe mounting prescribed area is inadequately repaired (5.3.6 (a) (i)) | 1 |
| Offside Front Subframe mounting prescribed area is inadequately repaired (5.3.6 (a) (i)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Rear Inner Vehicle structure inadequately repaired such that it is likely to adversely affect braking or steering (6.1.1 (d) (ii)) | 1 |
| Fluid leak harmful to the environment or a risk to other road users major coolant leak anti freeze everywhere (all over ramp and roller brake tester) (8.4.1 (a) (i)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Rear Exhaust silencer insecure clamp corroded (8.1.1 (b) (i)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Drivers airbag missing (7.1.5 (a)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Emissions oxygen sensor missing where one was fitted as standard post cat sensor (8.2.1.1 (a)) | 1 |
| Offside Emissions oxygen sensor missing where one was fitted as standard post cat sensor (8.2.1.1 (a)) | 1 |
| Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction dashcam/interior mirror ornaments (3.1 (a) (ii)) | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Suspension has inadequate clearance with the chassis |2.4.A.1a| | 1 |
| Emissions not tested (8.2.2.2 (e)) | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Inner Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Emissions unable to be completed Exhaust leak (8.2.1.2 (d)) | 1 |
| Side repeater missing both sides (4.4.1 (a) (ii)) | 1 |
| Offside Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp switch missing (4.5.3 (a)) | 1 |
| Rear fog lamp tell-tale missing (4.9.1 (a) (ii)) | 1 |
| Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Headlamp aim projected beam image is obviously incorrect both (4.1.2 (c)) | 1 |
| Front Inner Suspension arm pin or bush excessively worn lower bushes both sides (5.3.4 (a) (i)) | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Headlamp insecure |4.1.1 |c|| | 1 |
| Nearside Steering system fouling |2.2.D.2a| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Exhaust has a major leak of exhaust gases centre to cat |6.1.2 |a|| | 1 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Emissions not tested EXCESS SMOKE |7.3.A.1| | 1 |
| Rear brake application uneven | 1 |
| Nearside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn inner (5.3.4 (a) (i)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength both sides (5.3.6 (a) (i)) | 1 |
| Rear Sub-frame corroded and seriously weakened both sides (5.3.3 (b) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases jointing sleeve corroded and holed (6.1.2 (a)) | 1 |
| Front Track rod end ball joint has excessive play track rods (2.1.3 (b) (i)) | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced output below requirements |1.7.5a| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Headlamp cleaning device obviously defective both |1.7.2| | 1 |
| Nearside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Integral body structure inadequately repaired such that it is likely to adversely affect braking or steering Inner and outer sills (6.1.1 (d) (ii)) | 1 |
| Offside Rear Integral body structure inadequately repaired such that it is likely to adversely affect braking or steering Inner and out sills (6.1.1 (d) (ii)) | 1 |
| Coil spring corroded so that its cross sectional area is reduced and seriously weakened N/s and o/s rear (5.3.1 (b) (i)) | 1 |
| Nearside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Stop lamp adversely affected by the operation of another lamp high level lamp illuminates when side lights switched on |1.2.1f| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Nearside Front Steering rack insecure |2.2.B.1a| | 1 |
| Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Rear fog lamp missing |1.3.2a| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage ball joint likely to become detached nut re secured (5.3.4 (a) (ii)) | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill corroded through in front of suspension mounting point (5.3.6 (a) (i)) | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect Incorrectly fitted bulb (4.1.2 (c)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced floor area (7.1.1 (a) (i)) | 1 |
| Nearside Front Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits 0.97% (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits 1.03% (8.2.1.2 (a)) | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
| Nearside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Offside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Nearside Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Front Windscreen wiper blade missing (3.4 (b) (ii)) | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Headlamp cleaning device obviously defective |1.7.2| | 1 |
| Offside Front Headlamp cleaning device obviously defective |1.7.2| | 1 |
| Headlamp levelling device inoperative |1.7.2| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Headlamp aim so that beam "kick up" is not visible on the screen o/s+n/s |4.1.2 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Nearside Front suspension locking device missing |2.5.A.4| | 1 |
| Nearside Front suspension retaining device ineffective |2.5.A.4| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear Macpherson strut modified and seriously weakened |2.4.A.2| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Rear Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Vehicle structure has excessive corrosion which adversely affects braking or steering Centre |6.1.A.1| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Centre floor support damaged and corroded |6.1.B.2| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings middle of chassis |6.1.B.2| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |