| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Brake pipe excessively corroded | 9 |
| Headlamp aim out of alignment | 9 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 6 |
| Rear fog lamp missing |1.3.2a| | 6 |
| Registration plate lamp issues | 6 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 5 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 4 |
| Offside Front Direction indicator not working |1.4.A.2c| | 4 |
| Rear fog lamp tell tale missing |1.3.1b| | 4 |
| Rear fog lamp switch missing |1.3.1a| | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 3 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Registration plate issues | 2 |
| Nearside Rear Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Brake hydraulic reservoir leaking hydraulic fluid |3.6.A.1| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Rear Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Offside Rear Service brake excessively binding Suspect seized brake caliper |1.2.1 |f|| | 1 |
| Front Brake disc significantly and obviously worn Inner faces |1.1.14 |a| |i|| | 1 |
| Steering rack insecure |2.2.B.1a| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Nearside Rear Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Brakes imbalanced across an axle | 1 |
| Rear parking brake recording little or no effort | 1 |
| Emissions not tested |7.0| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside Front Front suspension retaining device missing |2.5.A.4| | 1 |
| Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Offside Front Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Brake pipe leaking on a hydraulic braking system to rear (1.1.11 (b) (ii)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Headlamp insecure |1.7.3| | 1 |
| Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front Horn not working (7.7 (a)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Fluid suspension unit leaking |2.4.D.2| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear wheel steering ball joint has excessive play |2.2.B.1i| | 1 |
| Offside Rear wheel steering ball joint has excessive play |2.2.B.1i| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Rear fog lamp obviously incorrectly positioned fitted to n/s not o/s of vehicle. |4.5.4 |a|| | 1 |
| Rear fog lamp switch missing |4.5.3 |a| |ii|| | 1 |
| Offside Rear Upper Suspension arm pin or bush excessively worn inner bush/poss bolt loose |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn inner bush |5.3.4 |a| |i|| | 1 |
| Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| front brake juddering severely |3.7.A.2b| | 1 |
| Horn not working |1.6.2a| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
| Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Fuel pipe leaking excessively or a risk of fire (6.1.3 (b) (ii)) | 1 |
| Offside Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Front Exhaust fumes entering cabin (6.1.2 (b) (i)) | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition (8.1.1 (a)) | 1 |
| Emissions unable to be completed major exhaust leak (8.2.1.2 (d)) | 1 |