| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 6 |
| Registration plate lamp issues | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Brakes imbalanced across an axle | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Rear parking brake recording little or no effort | 4 |
| Horn not working |1.6.2a| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Rear brake binding | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Lower Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside Front Anti-roll bar insecure |2.4.G.1| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Track rod end loose |2.2.B.1d| | 1 |
| Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Electrical wiring inadequately supported |1.9.2a| | 1 |
| Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Offside Rear Upper Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Main beam `tell-tale` not working not working with lamp |1.7.4c| | 1 |
| Headlamp aim beam image obviously incorrect both |1.8.A.1b| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Steering rack gaiter split both |2.2.D.2d| | 1 |
| Nearside Rear Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings bump stop |6.1.B.2| | 1 |
| Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings over wheel arch |6.1.B.2| | 1 |
| Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings both chassis end plates to body |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings floor |6.1.B.2| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Upper Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded floor |5.2.6| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded floor |5.2.6| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Front brake application uneven | 1 |
| Front front brakes release unevenly |3.7.B.4| | 1 |
| Exhaust emits clearly visible black smoke during acceleration |7.3.A.2c| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Front Tie bar/rod attachment bracket/mounting nut missing |2.4.G.1| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Front Steering system excessively rough |2.2.D.1| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Brake hose excessively deteriorated | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Centre Front Obligatory mirror insecure |8.1.1| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Torsion bar attachment bracket corroded and seriously weakened |2.4.E.4c| | 1 |
| Offside Front Tie bar/rod attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Upper Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Front Direction indicators not working |1.4.A.2c| | 1 |
| Rear Direction indicators not working |1.4.A.2c| | 1 |
| Windscreen wiper does not clear the windscreen effectively | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering two places |6.1.A.1| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Hydraulic brake cylinder leaking hydraulic fluid (1.1.16 (b) (i)) | 1 |
| Nearside Rear Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Floorpan and B post (7.1.1 (a) (i)) | 1 |
| Offside Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced Inner Sill Area (7.1.1 (a) (i)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Parking (secondary brake) on a single line braking system imbalanced across an axle Axle 1 (1.3.1 (b) (i)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |