| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 28 |
| Brakes imbalanced across an axle | 20 |
| Rear brake binding | 15 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 14 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 12 |
| Offside Stop lamp not working |1.2.1b| | 11 |
| Nearside Stop lamp not working |1.2.1b| | 11 |
| Registration plate issues | 9 |
| Rear brake application uneven | 8 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Offside Rear fog lamp not working |1.3.2b| | 7 |
| Rear fog lamp not working |1.3.2b| | 6 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 6 |
| Registration plate lamp issues | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Offside Headlamp not working on main beam |1.7.5a| | 5 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 5 |
| Horn not working |1.6.2a| | 5 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 5 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 5 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 5 |
| Rear fog lamp tell tale not working |1.3.1b| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 3 |
| Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Front brake excessively fluctuating | 3 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Nearside Rear Service brake lagging in operation (1.2.1 (d)) | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 3 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Brake pipe excessively corroded | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Steering wheel weakened by fractures |2.1.1| | 2 |
| Nearside Front Wheel insecure |4.2.A.1c| | 2 |
| Nearside Rear Wheel insecure |4.2.A.1c| | 2 |
| Offside Rear Wheel insecure |4.2.A.1c| | 2 |
| Front brake application uneven | 2 |
| Nearside Rear Wheel nut|s| loose |4.2.A.1e| | 2 |
| Brake pedal has insufficient reserve travel |1.1.2 |a|| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Brake pedal anti-slip provision missing |1.1.2 |c|| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Nearside Front Shock absorber insecure |2.7.2b| | 2 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| rear brakes release unevenly |3.7.B.4| | 2 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Windscreen washer not working | 2 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Brake hose excessively deteriorated | 2 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
| Emissions unable to be completed (8.2.1.2 (d)) | 2 |
| Horn sounds harsh or grating |1.6.2e| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Centre Front Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Nearside Rear Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Front Outer Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Centre Front Indicator switch insecure |1.4.A.1| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Front Steering lock stop incorrectly adjusted |2.2.D.2c| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Tie bar/rod insecure |2.4.G.1| | 1 |
| Offside Front Brake hose leaking |3.6.A.1| | 1 |
| Nearside Front Front position lamp|s| flickers when tapped lightly by hand |1.1.4c| | 1 |
| Steering wheel retaining device insecure |2.1.6| | 1 |
| Central Rear Parking brake lever ratchet not holding correctly |1.1.6 |a|| | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Inner Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Shock absorber detached |2.7.2b| | 1 |
| Offside Front Shock absorber detached |2.7.2b| | 1 |
| An item not tested |Manual| | 1 |
| Nearside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Stop lamp|s| remains on when the brakes are released |4.3.2 |a| |iii|| | 1 |
| Offside Stop lamp|s| remains on when the brakes are released |4.3.2 |a| |iii|| | 1 |
| Offside Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Offside Front Wheel insecure |4.2.A.1c| | 1 |
| Nearside Lower Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Offside Rear Road wheel fixing loose |5.2.1 |a| |i|| | 1 |
| Offside Rear Service brake has no recorded effort at a wheel |1.2.1 |a| |ii|| | 1 |
| Offside Rear Wheel nut|s| loose |4.2.A.1e| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Vehicle Identification Number not permanently displayed |6.3.5.a| | 1 |
| Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Brake hose leaking on a hydraulic braking system |1.1.12 |c| |ii|| | 1 |
| Offside Front Brake hose leaking on a hydraulic braking system |1.1.12 |c| |ii|| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Nearside Front Axle king pin so loose it is likely to affect directional stability |5.1.2 |d| |ii|| | 1 |
| Offside Front Axle king pin so loose it is likely to affect directional stability |5.1.2 |d| |ii|| | 1 |
| Brake lever has insufficient reserve travel |1.1.2 |a|| | 1 |
| Offside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen |3.5 |a|| | 1 |
| Nearside Rear Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Offside Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Nearside Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Windscreen in such a condition that visibility through swept area is seriously affected |3.2 |c| |ii|| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Lower Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Nearside Front Front suspension has excessive movement at a tie bar joint |2.5.A.1c| | 1 |
| Nearside Front Suspension component mounting prescribed area is fractured |2.4.A.3| | 1 |
| Front Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Upper Shock absorber insecure |2.7.2b| | 1 |
| Offside Front Lower Vehicle structure has excessive corrosion which adversely affects braking or steering chassis rail with outer wing support |6.1.A.1| | 1 |
| Nearside Front Vehicle structure is fractured and structural rigidity is significantly reduced |6.1.1 |a| |i|| | 1 |
| Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Nearside Front Lower Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Horn is a siren |1.6.2c| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front brake disc contaminated by oil |3.5.1h| | 1 |
| Offside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Steering box insecure |2.2.B.1a| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Nearside Rear wheel cylinder has restricted free movement |3.5.1k| | 1 |
| Offside Rear wheel cylinder has restricted free movement |3.5.1k| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Suspension arm attachment bracket/mounting cracked |2.4.G.1| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Fluid suspension unit leaking |2.4.D.2| | 1 |
| Offside Front Fluid suspension unit leaking |2.4.D.2| | 1 |
| Offside Front Windscreen wiper blade missing |8.2.2| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Front Fuel pipe union leaking |7.2.3| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Service brake indicates brake bind |3.7.D.2a| | 1 |
| Offside Rear Service brake indicates brake bind |3.7.D.2a| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Nearside Rear Service brake lagging in operation |1.2.1 |d|| | 1 |
| Nearside Front Steering linkage ball joint ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Drive shaft joint so worn it is likely to fail (6.1.7 (c) (ii)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner wing/engine compartment (6.2.2 (d) (i)) | 1 |
| Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Headlamp not working on main beam Both (4.1.1 (a) (ii)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Parking brake lever ratchet not holding correctly (1.1.6 (a)) | 1 |
| Offside Front Road wheel fixing loose (5.2.1 (a) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
| Offside Rear Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
| Offside Front Hydraulic fluid leaking continuously posing a serious risk to road safety brake master cylinder (8.4.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Headlamp has a product on the light source so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Rear Road wheel fixing loose (5.2.1 (a) (i)) | 1 |
| Offside Obligatory mirror missing (3.3 (a)) | 1 |
| Brake fluid significantly below minimum mark (1.1.10 (d) (ii)) | 1 |
| Nearside Rear Road wheel fixing loose (5.2.1 (a) (i)) | 1 |
| Front Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Nearside Front Lower Suspension component insecurely attached (5.3.3 (a) (i)) | 1 |
| Offside Front Lower Suspension component insecurely attached (5.3.3 (a) (i)) | 1 |
| Offside Rear Fuel pipe union leaking (6.1.3 (b) (i)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect dip (4.1.2 (c)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Fuel pipe leaking at fuel filter (6.1.3 (b) (i)) | 1 |
| Emissions unable to be completed radiator leaking (8.2.1.2 (d)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt is insecure (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt is insecure (2.1.3 (g) (ii)) | 1 |
| Nearside Front Road wheel fixing loose (5.2.1 (a) (i)) | 1 |
| Nearside Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions unable to be completed major leak of gases (8.2.1.2 (d)) | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Steering box has excessive free play detected at the steering wheel to the extent that safe steering is affected (steering box fitted) steering box insecure chassis snaped (2.3 (a) (ii)) | 1 |
| Parking brake lever is not capable of being maintained in operation by direct mechanical action only (1.1.6 (f)) | 1 |
| Nearside Rear Brake valve leaking (1.1.7 (d) (i)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |