Most common failures | No# failures |
---|
Brake pipe excessively corroded | 20 |
Windscreen wiper does not clear the windscreen effectively | 17 |
Brakes imbalanced across an axle | 16 |
Headlamp aim out of alignment | 15 |
Offside Rear fog lamp not working |1.3.2b| | 15 |
Registration plate lamp issues | 12 |
Parking brake: efficiency below requirements |3.7.B.7| | 8 |
Service brake: efficiency below requirements |3.7.B.7| | 7 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 7 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
Rear fog lamp not working |1.3.2b| | 6 |
Rear fog lamp tell tale not working |1.3.1b| | 6 |
Nearside Steering pivot point has excessive play |2.2.B.1g| | 6 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 5 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 4 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 4 |
Offside Rear Shock absorber detached |2.7.2b| | 4 |
Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Rear parking brake recording little or no effort | 4 |
Nearside Stop lamp not working |1.2.1b| | 3 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 3 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 3 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 3 |
Exhaust system not adequately supported |7.1.1| | 3 |
Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 3 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 3 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 3 |
Parking brake lever has no reserve travel |3.1.6b| | 3 |
Emissions not tested |7.0| | 3 |
Rear Rear fog lamp not working |1.3.2b| | 3 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
Rear fog lamp emits a light other than red |1.3.2e| | 2 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
Brake load sensing valve seized |3.6.E.3| | 2 |
Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Front front brake binding |3.7.B.1| | 2 |
Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
Exhaust emissions exceed level of metered smoke for a non-turbo charged engine (8.2.2.2 (b)) | 2 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 2 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Rear Exhaust has a part missing |7.1.1a| | 2 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Obligatory mirror insecure |8.1.1| | 2 |
Power steering component|s| leaking |2.3.3b| | 2 |
Offside Front Ball joint has excessive play |2.2.B.1f| | 2 |
Windscreen wiper blade insecure | 2 |
Offside front brake binding |3.7.B.1| | 2 |
Front brake excessively fluctuating | 2 |
Offside Ball joint has excessive play |2.2.B.1f| | 2 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 2 |
Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.2| | 1 |
Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting O/S/F inner wing at front and rear
N/S/F inner wing at rear
O/S/F at body mounting
O/S/R crossmember |6.2.2 |d| |i|| | 1 |
Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Anti-roll bar pin or bush excessively worn front outer bushes worn |5.3.4 |a| |i|| | 1 |
Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Semaphore indicator switch missing |1.4.C.1c| | 1 |
Horn not working |1.6.2a| | 1 |
Front Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Offside Rear fog lamp missing |1.3.2a| | 1 |
Front Power steering inoperative |2.3.3a| | 1 |
Offside Front Power steering component|s| leaking |2.3.3b| | 1 |
Nearside Front Torsion bar excessive play at an end fixing |2.4.E.2| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
Battery insecure |1.9.1| | 1 |
Nearside Rear Leaf spring cracked |2.4.B.1a| | 1 |
Offside Rear Rear fog lamp not working switch getting hot |1.3.2b| | 1 |
Offside Rear Shock absorber detached broken away from chassis |2.7.2b| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Spare wheel carrier insecure |6.4.2| | 1 |
Offside Front Brake pipe leaking |3.6.A.1| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
Front brake application uneven | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
Offside Rear reflector missing |1.5.1a| | 1 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Speedometer clearly inoperative |6.7.2| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Horn not a continuous or uniform sound |1.6.2e| | 1 |
Nearside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Offside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Intermediate drop arm deformed and unserviceable |2.2.C.1d| | 1 |
Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Rear Leaf spring fractured |2.4.B.1a| | 1 |
Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Rear Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Offside Front Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Brake hose excessively deteriorated | 1 |
Nearside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Rear brake application uneven | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Nearside Front Shock absorber detached |2.7.2b| | 1 |
Offside Front Shock absorber detached |2.7.2b| | 1 |
Power steering malfunctioning |2.3.3a| | 1 |
Nearside Rear Upper Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Nearside Rear Lower Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Offside Rear Upper Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Offside Rear Lower Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Nearside Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Drag link end ball pin shank loose |2.2.B.1c| | 1 |
Steering system excessively rough |2.2.D.1| | 1 |
Offside Power steering component|s| leaking |2.3.3b| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
Nearside Rear Body has a projection caused by corrosion |6.1.C.1| | 1 |
Rear fog lamp switch insecure |1.3.1a| | 1 |
Nearside Front Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Rear position lamp|s| incomplete |1.1.4a| | 1 |
Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Drag link end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Rear fog lamp switch inoperative |4.5.3 |a| |ii|| | 1 |
Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
Offside Front Position lamp not working |4.2.1 |a|| | 1 |
Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
Central Prop shaft bearing excessively worn |6.1.7 |b| |i|| | 1 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength shock mount (5.3.6 (a) (i)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
Nearside Rear Shock absorber insecure |2.7.2b| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outer sill |6.1.B.2| | 1 |
Offside Outer Front Brake hose leaking |3.6.A.1| | 1 |
Offside Inner Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Nearside Inner Front Brake hose leaking |3.6.A.1| | 1 |
Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Towbar retaining device missing |6.6.3a| | 1 |
Rear brake binding | 1 |
Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Offside Rear Brake pipe excessively damaged (1.1.11 (c)) | 1 |
Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Offside Rear Leaf spring shackle pin or bush likely to become detached bolts missing (5.3.4 (a) (ii)) | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Nearside Front Brake pipe excessively damaged |3.6.B.2c| | 1 |
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Steering box has a significant oil leak |2.2.D.2e| | 1 |
Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Lower Shock absorber insecure |2.7.2b| | 1 |
Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Nearside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
Offside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
Nearside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
Offside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis leg at spring mounting (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis leg at spring mounting area (5.3.6 (a) (i)) | 1 |
Nearside Front Lower Shock absorbers has an excessively worn bush bush (5.3.2 (c)) | 1 |
Offside Front Lower Shock absorbers has an excessively worn bush bush (5.3.2 (c)) | 1 |
Prop shaft bearing excessively worn centre bearing (6.1.7 (b) (i)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Power steering pipe|s| or hose|s| leaking from a seal |2.3.3b| | 1 |
Nearside Front Shock absorber insecure |2.7.2b| | 1 |
Offside Front Ball joint ball pin shank loose |2.2.B.1c| | 1 |
Offside Rear Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
Nearside Rear Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Stop lamp not working |1.2.1b| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Shock absorber detached |2.7.2b| | 1 |
Nearside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
Offside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Inner Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Front Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Headlamp insecure both insecure (4.1.1 (c)) | 1 |
Shock absorbers has an excessively worn bush both front (5.3.2 (c)) | 1 |
Track rod end ball joint has excessive play both front (2.1.3 (b) (i)) | 1 |
Front drive shaft coupling is excessively worn |2.5.C.1c| | 1 |
Rear Brake pivot has restricted free movement pivot arm |1.1.15 |e|| | 1 |
Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Exhaust has a major leak of exhaust gases intermediate pipe holed |6.1.2 |a|| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis holed close to leaf spring mount |5.3.6 |a| |i|| | 1 |