| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 11 |
| Brake pipe excessively corroded | 9 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 6 |
| Registration plate issues | 6 |
| Rear parking brake recording little or no effort | 6 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 3 |
| Offside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 3 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Registration plate lamp issues | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Horn not working (7.7 (a)) | 2 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Offside Front Direction indicator likely to become detached (4.4.1 (c) (ii)) | 2 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
| Brakes imbalanced across an axle | 2 |
| Windscreen has damage | 2 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Driver`s door does not latch securely closed |6.2.B.1a| | 1 |
| Windscreen wiper blade insecure | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Offside Rear Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Windscreen washer control missing |8.2.1a| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Upper Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Upper Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Lower Hydraulic brake calliper insecurely mounted (1.1.16 (c) (i)) | 1 |
| Offside Front Lower Hydraulic brake calliper insecurely mounted (1.1.16 (c) (i)) | 1 |
| Offside Front Lower Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting floor (6.2.2 (d) (i)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill (6.2.2 (d) (i)) | 1 |
| Nearside Front Steering locking device missing |2.2.C.1g| | 1 |
| Offside Front Steering locking device missing |2.2.C.1g| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis rail (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength side chassis rail (5.3.6 (a) (i)) | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis rail (5.3.6 (a) (i)) | 1 |
| Offside Rear Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis rail (5.3.6 (a) (i)) | 1 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Emission control equipment obviously defective cat missing (8.2.1.1 (a)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear Anti-roll bar pin or bush excessively worn x2 (5.3.4 (a) (i)) | 1 |
| Nearside Front Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor near sill front (5.3.6 (a) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Front Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Offside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Nearside Rear Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Offside Rear Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor |5.3.6 |a| |i|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Front Position lamp light intensity significantly reduced |4.2.3 |a| |ii|| | 1 |
| Nearside Headlamp lens seriously defective |4.1.1 |b| |ii|| | 1 |
| Offside Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
| Exhaust catalytic converter missing where one was fitted as standard |8.2.1.1 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear fog lamp adversely affected by the operation of another lamp |1.3.2f| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Front brake application uneven | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Electrical wiring insecure Engine Bay |1.9.2a| | 1 |
| Electrical wiring insecure Underneath |1.9.2a| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected Floor. (5.3.6 (a) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Chassis leg. (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area fractured to the extent that control of the vehicle is likely to be adversely affected Inner sill (5.3.6 (a) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Chassis leg (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area fractured to the extent that control of the vehicle is likely to be adversely affected Inner sill. (5.3.6 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar insecurely attached (5.3.3 (a) (i)) | 1 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Stop lamp(s) not working 1 lamp (4.3.1 (a) (ii)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Front Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Rear Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Rear Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner arch (6.1.1 (c) (i)) | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis (6.1.1 (c) (i)) | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis (6.1.1 (c) (i)) | 1 |
| Nearside Front Anti-lock braking system wiring excessively damaged abs wire insecure (1.6 (d)) | 1 |
| Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Fuel pipe excessively damaged |7.2.2| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |