| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 179 |
| Windscreen wiper does not clear the windscreen effectively | 105 |
| Registration plate lamp issues | 96 |
| Headlamp aim out of alignment | 64 |
| Offside Rear fog lamp not working |1.3.2b| | 48 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 28 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 24 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 23 |
| Registration plate issues | 19 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 18 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 17 |
| Rear fog lamp not working |1.3.2b| | 17 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 13 |
| Offside Rear fog lamp missing |1.3.2a| | 12 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 12 |
| Nearside Stop lamp not working |1.2.1b| | 11 |
| Horn not working |1.6.2a| | 11 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 11 |
| Rear fog lamp tell tale not working |1.3.1b| | 11 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 11 |
| Horn not working (7.7 (a)) | 11 |
| Windscreen washer not working | 10 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 10 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 10 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 10 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 9 |
| Anti-lock braking system warning lamp indicates an ABS fault | 9 |
| Offside Rear fog lamp insecure |1.3.2a| | 9 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 9 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 9 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 9 |
| Brakes imbalanced across an axle | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 8 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 8 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 8 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 8 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 8 |
| Offside Stop lamp not working |1.2.1b| | 7 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 7 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 7 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Ball joint has excessive play |2.2.B.1f| | 6 |
| Rear fog lamp switch missing |1.3.1a| | 6 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 6 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 6 |
| Battery insecure |1.9.1| | 6 |
| Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b)) | 6 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 6 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 6 |
| Offside Rear Shock absorbers has a serious fluid leak | 6 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 6 |
| Parking brake lever has no reserve travel |3.1.6b| | 5 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Nearside front brake binding |3.7.B.1| | 5 |
| Rear brake binding | 5 |
| Rear parking brake recording little or no effort | 5 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 5 |
| Offside front brake binding |3.7.B.1| | 5 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 5 |
| Emissions not tested |7.0| | 5 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 5 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 5 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 5 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 5 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 5 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 5 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 4 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 4 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 4 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i)) | 4 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 4 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Trailer electrical socket insecure |1.9.3a| | 4 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 4 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 4 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 4 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 4 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 4 |
| Rear Exhaust system insecure (6.1.2 (a)) | 4 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 4 |
| Nearside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 4 |
| Offside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 4 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 4 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 4 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 4 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Offside Rear Stop lamp not working |1.2.1b| | 4 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 4 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
| Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Brake performance not tested (1.2.1 (g)) | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 3 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced wheel arch (7.1.1 (a) (i)) | 3 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Rear Rear fog lamp not working |1.3.2b| | 3 |
| Windscreen wiper blade insecure | 3 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Front brake application uneven | 3 |
| Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Centre Exhaust system not adequately supported |7.1.1| | 3 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 3 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Oil leaking continuously from engine posing a serious risk to road safety (8.4.1 (a) (ii)) | 3 |
| Brake hose excessively deteriorated | 3 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 3 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 3 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 3 |
| Offside Front Shock absorbers has a serious fluid leak | 3 |
| Offside Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 3 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 3 |
| Nearside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 3 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 3 |
| Offside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 3 |
| Offside Rear Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 3 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 3 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 3 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 3 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 3 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 3 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Rear Fuel pipe leaking |7.2.3| | 3 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 3 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 3 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Windscreen has damage | 3 |
| Offside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 3 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 3 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |