| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 39 |
| Windscreen wiper does not clear the windscreen effectively | 36 |
| Headlamp aim out of alignment | 35 |
| Registration plate lamp issues | 30 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 14 |
| Registration plate issues | 13 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 12 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 11 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 10 |
| Brakes imbalanced across an axle | 8 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 8 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 8 |
| Windscreen has damage | 8 |
| Offside Rear fog lamp not working |1.3.2b| | 7 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 7 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Front brake application uneven | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 4 |
| Rear Exhaust system not adequately supported |7.1.1| | 4 |
| Horn not working |1.6.2a| | 4 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Offside Headlamp insecure |1.7.3| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear Brake load sensing valve defective and function impaired |3.6.E.3| | 2 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Brake performance not tested (1.2.1 (g)) | 2 |
| Nearside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 2 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Emissions not tested |7.0| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength both under sills |5.3.6 |a| |i|| | 1 |
| Nearside Rear Leaf spring shackle pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded sill near mount |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded sill near mount |2.4.A.3| | 1 |
| Braking system leaking front to rear leaking |3.6.A.1| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Brake performance not tested Corroded pipes (1.2.1 (g)) | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Rear Suspension spring mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected outer sill |5.3.6 |a| |ii|| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded floor antiroll bar area |2.4.A.3| | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill |6.2.2 |d| |i|| | 1 |
| Offside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill front |6.1.B.2| | 1 |
| Offside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill rear |6.1.B.2| | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Suspension spring mounting prescribed area is excessively corroded nearside rear outrigger |2.4.A.3| | 1 |
| Suspension spring mounting prescribed area is excessively corroded offside rear outrigger |2.4.A.3| | 1 |
| Nearside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Power steering component|s| leaking |2.3.3b| | 1 |
| Offside Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Offside Front Exhaust has a major leak of exhaust gases Down pipe to cat joint excessive blow (6.1.2 (a)) | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Chassis out rigger (6.1.1 (c) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Lower step (6.1.1 (c) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill (5.3.6 (a) (i)) | 1 |
| Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner sill (5.3.6 (a) (i)) | 1 |
| Rear Brake valve leaking such that brake functionality is affected No performance at rear service brake (1.1.7 (d) (ii)) | 1 |
| Offside Rear Inner Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Step (6.1.1 (c) (i)) | 1 |
| Nearside Steering linkage ball joint has excessive play Inner steering joint (2.1.3 (b) (i)) | 1 |
| Nearside Rear Inner Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Spare wheel insecure in carrier (6.1.5 (b) (i)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Leaf spring cracked |2.4.B.1a| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Rear Rear fog lamp not visible from a reasonable distance |1.1.6b| | 1 |
| Nearside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded floor |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded front spring mounting outer sill |2.4.A.3| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Emissions not tested Rear exhaust section in poor condition |7.3.A.1| | 1 |
| Offside Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Front Steering column shaft has excessive end float |2.1.3| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Position lamp lens seriously defective (4.2.1 (b)) | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength out rigger (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength out rigger (5.3.6 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage attachment bracket/mounting fractured (5.3.3 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage missing (5.3.3 (a) (ii)) | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded inner wheelarch |2.4.A.3| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded inner wheelarch |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded quarter panel behind wheelarch |2.4.A.3| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded quarter panel behind wheelarch |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded inner quarter panel behind wheelarch |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded chassis outrigger between inner sill and spring hanger |2.4.A.3| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded inner rear panel |2.4.A.3| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area is excessively corroded lower wheel arch |2.4.A.3| | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded Sill panel outer MIY |2.4.A.3| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Outer Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Outer Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired (5.3.6 (a) (i)) | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Beam (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Beam (5.3.6 (a) (i)) | 1 |
| Spare wheel carrier insecure |6.4.2| | 1 |
| Offside Rear Shock absorber insecure |2.7.2b| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside Lower Front suspension has excessive play in an outer ball joint |2.5.B.2a| | 1 |
| Nearside Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Rear Brake load sensing valve seized |3.6.E.3| | 1 |
| Offside Front Lower Subframe mounting prescribed area excessively corroded significantly reducing structural strength Outer sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Lower Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength Sill (5.3.6 (a) (i)) | 1 |
| Nearside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Emissions not tested due to rad burst during test |8.2.1.2 |d|| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded floor pan |2.2.C.1h| | 1 |
| Offside Body has a sharp edge caused by corrosion door |6.1.C.1| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion wheel arch |6.1.C.1| | 1 |
| Nearside Front Upper Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Lower Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Upper Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Lower Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Rear reflector excessively deteriorated so that its function is impaired |1.5.1c| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
| Nearside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust has a major leak of exhaust gases centre box (6.1.2 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Brake load sensing valve inoperative and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Vehicle Identification Number not permanently displayed |6.3.5.a| | 1 |
| Offside Rear fog lamp does not face the rear |1.3.2a| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Front Direction indicators not working |1.4.A.2c| | 1 |
| Rear Direction indicators not working |1.4.A.2c| | 1 |