| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 23 |
| Headlamp aim out of alignment | 13 |
| Service brake: efficiency below requirements |3.7.B.7| | 10 |
| Registration plate lamp issues | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Offside Rear fog lamp not working |1.3.2b| | 6 |
| Brake hose excessively deteriorated | 6 |
| Registration plate issues | 5 |
| Brakes imbalanced across an axle | 5 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
| Centre Exhaust system not adequately supported |7.1.1| | 4 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Offside Rear Rear position lamp|s| incomplete |1.1.4a| | 3 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside front brake binding |3.7.B.1| | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Front front brake binding |3.7.B.1| | 3 |
| Offside Front front brake binding |3.7.B.1| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
| Ball joint has excessive play |2.2.B.1f| | 2 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
| Offside Rear position lamp|s| incomplete |1.1.4a| | 2 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front Brake pipe inadequately supported |3.6.B.1| | 2 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Exhaust mounting missing |7.1.1b| | 2 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Rear brake application uneven | 2 |
| Nearside Rear Leaf spring fractured |2.4.B.1a| | 2 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 2 |
| Battery insecure |1.9.1| | 2 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Shock absorber casing damaged externally so the unit does not function |2.7.2a| | 1 |
| Offside Front Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Inner Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Fuel cap/sealing device ineffective |6.1.3 |b| |i|| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear brake binding | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Tie bar/rod worn and seriously weakened |2.4.G.1| | 1 |
| Offside Front Tie bar/rod worn and seriously weakened |2.4.G.1| | 1 |
| Centre Rear Front drive shaft coupling flexible rubber or fabric coupling unit breaking up |2.5.C.1d| | 1 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Rear fog lamp not working |1.3.2b| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Leaf spring cracked |2.4.B.1a| | 1 |
| Nearside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Front brake application uneven | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Front Steering lock stop missing |2.2.D.2c| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Inner Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside Rear Position lamp showing white light to the rear |4.2.3 |a| |ii|| | 1 |
| Nearside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting |6.2.2 |d| |i|| | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced spring mounting |6.1.1 |c| |i|| | 1 |
| Nearside Front Body panel corroded and likely to cause injury wing |6.2.1 |a| |i|| | 1 |
| Nearside Rear Leaf spring fractured |5.3.1 |b| |i|| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear front brake binding |3.7.B.1| | 1 |
| Offside Rear front brake binding |3.7.B.1| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside An item not tested |Manual| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Offside Upper Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
| Nearside Front Intermediate drop arm fractured and unserviceable |2.2.C.1d| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Front Shock absorber insecure |2.7.2b| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Windscreen wiper blade insecure | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Horn not working |1.6.2a| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Shock absorber detached |2.7.2b| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |