| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 12 |
| Brake pipe excessively corroded | 12 |
| Headlamp aim out of alignment | 7 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 7 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 7 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 5 |
| Emissions not tested |7.0| | 3 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Registration plate lamp issues | 2 |
| Brake performance not tested |3.7.A.1| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Upper Stop lamp not working |1.2.1b| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Rear fog lamp missing |1.3.2a| | 2 |
| Rear fog lamp switch missing |1.3.1a| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Inner Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.1 |c| |ii|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Front Headlamp insecure |4.1.1 |c|| | 1 |
| Nearside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Rear Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Suspension component mounting prescribed area is excessively corroded Offside rear chassis rail |2.4.A.3| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Rear Rear fog lamp has a product on the lens so it is not visible from a reasonable distance |1.3.2d| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Macpherson strut has excessive movement in the upper support bearing assembly |2.5.B.1b| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Brakes imbalanced across an axle | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Rear Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Lower Suspension arm pin or bush excessively worn inner bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Fuel system component leaking (6.1.3 (b) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis holed under suspension arm mounting (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis holed under suspension arm mounting (5.3.6 (a) (i)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill front to rear (7.1.1 (a) (i)) | 1 |
| Nearside Front Shock absorbers damaged to the extent that it does not function (5.3.2 (b)) | 1 |
| Suspension arm ball joint likely to become detached nut missing off bolt (5.3.4 (a) (ii)) | 1 |