| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 587 |
| Windscreen wiper does not clear the windscreen effectively | 587 |
| Headlamp aim out of alignment | 469 |
| Registration plate lamp issues | 168 |
| Registration plate issues | 131 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 88 |
| Anti-lock braking system warning lamp indicates an ABS fault | 83 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 76 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 75 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 65 |
| Rear brake binding | 56 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits (7.3.D.3) | 56 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 54 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 54 |
| Brakes imbalanced across an axle | 53 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 51 |
| Rear brake disc in such a condition that it is seriously weakened | 49 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 48 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 43 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 43 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 42 |
| Rear Exhaust system not adequately supported (7.1.1) | 36 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 34 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 33 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 33 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 31 |
| Rear Exhaust has a major leak of exhaust gases (7.1.2) | 31 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 31 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 30 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 28 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 27 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 27 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 27 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 25 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 25 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 24 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 24 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 23 |
| Nearside Front position lamp(s) not working (1.1.A.3b) | 23 |
| Rear Exhaust system not adequately supported |7.1.1| | 22 |
| Rear parking brake recording little or no effort | 22 |
| Nearside Track rod end ball joint has excessive play (2.2.B.1f) | 22 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 22 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 22 |
| Parking brake: efficiency below requirements (3.7.B.7) | 21 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 21 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 20 |
| Windscreen washer not working | 20 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 20 |
| Offside Front position lamp(s) not working (1.1.A.3b) | 20 |
| Offside Front Track rod end ball joint has excessive play (2.2.B.1f) | 19 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 19 |
| Windscreen has damage | 18 |
| Fuel cap/sealing device sealing washer deteriorated (7.2.4c) | 18 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 18 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 18 |
| Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 17 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 16 |
| Emissions not tested (8.2.1.2 (d)) | 16 |
| Offside Track rod end ball joint has excessive play (2.2.B.1f) | 16 |
| Brake hose excessively deteriorated | 15 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 15 |
| Nearside Front Track rod end ball joint has excessive play (2.2.B.1f) | 15 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 15 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 14 |
| Exhaust has a major leak of exhaust gases (7.1.2) | 14 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 14 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 14 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement (2.4.G.2) | 14 |
| Offside Stop lamp not working (1.2.1b) | 14 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 14 |
| Offside Stop lamp not working |1.2.1b| | 13 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 13 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 13 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement (2.4.G.2) | 13 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 13 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 13 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 13 |
| Front brake disc in such a condition that it is seriously weakened | 12 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 12 |
| Parking brake: efficiency below requirements |3.7.B.7| | 12 |
| Offside Front Shock absorbers has a serious fluid leak | 12 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 12 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 12 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 12 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 12 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 11 |
| Rear Mechanical brake component has restricted free movement | 11 |
| Offside Side repeater not working (1.4.A.2c) | 11 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 11 |
| Rear Exhaust system insecure (6.1.2 (a)) | 11 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 10 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 10 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone A (8.3.1e) | 10 |
| Nearside Front wheel bearing has excessive play (2.5.A.3c) | 10 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 10 |
| Nearside Stop lamp not working (1.2.1b) | 10 |