| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 27 |
| Registration plate lamp issues | 15 |
| Windscreen wiper does not clear the windscreen effectively | 15 |
| Brakes imbalanced across an axle | 11 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 9 |
| Horn not working |1.6.2a| | 7 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Offside Stop lamp not working |1.2.1b| | 6 |
| Nearside Stop lamp not working |1.2.1b| | 6 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 6 |
| Brake pipe excessively corroded | 5 |
| Anti-lock braking system warning lamp indicates an ABS fault | 5 |
| Rear parking brake recording little or no effort | 5 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Front brake application uneven | 3 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 3 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Registration plate issues | 3 |
| Rear brake binding | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Windscreen has damage | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Emissions not tested |7.0| | 2 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 2 |
| Offside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Body insecure and dangerous to other road users |6.1.B.1b| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i)) | 2 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i)) | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Nearside Rear Radius arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Rear fog lamp switch faulty |1.3.1a| | 2 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting |6.2.2 |d| |i|| | 1 |
| Rear Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Front Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Front suspension has a suspension lower ball joint securing nut not locked |2.5.B.1a| | 1 |
| Nearside Front Suspension arm locating pin insecure |2.4.G.3a| | 1 |
| Rear brake application uneven | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Floor/sill (5.3.6 (a) (i)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 1 |
| Offside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Suspension arm rubber mounting deteriorated resulting in excessive movement front bush |2.4.G.2| | 1 |
| Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Lower Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Upper Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced sill top (7.1.1 (a) (i)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Power steering pipe|s| or hose|s| leaking pipe above steering rack |2.3.3b| | 1 |
| Nearside Front Inner Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chalked (5.3.6 (a) (i)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| front parking |secondary| brakes imbalanced pulls to nearside |3.7.B.6b| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded floor |2.4.A.3| | 1 |
| Emissions not tested rear exhaust broken |7.4.B.1| | 1 |
| Nearside Front coil spring corroded so that its cross sectional area is reduced and seriously weakened |2.4.C.1b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Rear Upper Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Front rear brake juddering severely |3.7.A.5b| | 1 |
| Nearside Rear Upper Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Upper Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Position lamp light intensity significantly reduced |4.2.3 |a| |ii|| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Nearside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Front Brake hose leaking |3.6.A.1| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Horn not working relay can be heard clicking |1.6.2a| | 1 |
| Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Nearside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Nearside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Upper Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Offside Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Offside Front Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Exhaust system not adequately supported rear silencer rear mount loose |7.1.1| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Floor |5.3.6 |a| |i|| | 1 |
| Exhaust emissions exceed manufacturer`s specified limit |8.2.2.2 |a|| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt wheel end (6.1.7 (g) (ii)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt hub lower (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt top arm (5.3.4 (b) (ii)) | 1 |
| Front Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 1 |
| Nearside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Outer Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Rear Suspension arm worn and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Central Seat belt missing possible under rear seat child seat fitted (7.1.2 (a)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced floor and chassis corrosion (7.1.1 (a) (i)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn inner bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn inner bush (5.3.4 (a) (i)) | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| brake disc in such a condition that it is seriously weakened both rear |3.5.1i| | 1 |