Most common failures | No# failures |
---|
Headlamp aim out of alignment | 21 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 12 |
Registration plate lamp issues | 11 |
Brakes imbalanced across an axle | 10 |
Windscreen wiper does not clear the windscreen effectively | 9 |
Parking brake: efficiency below requirements |3.7.B.7| | 6 |
Rear brake binding | 5 |
Horn not working |1.6.2a| | 5 |
Nearside Steering rack gaiter split |2.2.D.2d| | 4 |
Registration plate issues | 4 |
Mechanical brake component has restricted free movement | 3 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
Fuel system component leaking |7.2.3| | 3 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 3 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Brake pipe excessively corroded | 3 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Rear Wheel insecure |4.2.A.1c| | 2 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Brake hose excessively deteriorated | 2 |
Nearside Stop lamp not working |1.2.1b| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Stop lamp not working |1.2.1b| | 2 |
Brake hose has insufficient room to move | 2 |
Offside Steering rack gaiter split |2.2.D.2d| | 2 |
Hazard warning switch faulty |1.4.B.1d| | 2 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Rear Stop lamp not working |1.2.1b| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside front brake binding |3.7.B.1| | 2 |
Horn emits two or more alternating tones |1.6.2d| | 2 |
Main beam `tell-tale` not working |1.7.4c| | 2 |
Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 2 |
Hazard warning lamps inoperative |1.4.B.1b| | 2 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Parking brake lever has no reserve travel |3.1.6b| | 2 |
Offside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Stop lamp remains on when the brakes are released | 2 |
Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
Direction indicators not working |1.4.A.2c| | 1 |
Nearside Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
Nearside Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
Windscreen has damage | 1 |
Nearside Front Wheel insecure |4.2.A.1c| | 1 |
Offside Front Wheel insecure |4.2.A.1c| | 1 |
Nearside Rear Wheel insecure |4.2.A.1c| | 1 |
Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Offside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
Offside Rear Road wheel fixing loose (5.2.1 (a) (i)) | 1 |
Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
Nearside Rear Mechanical brake component locking device missing |3.5.1l| | 1 |
Offside Rear Mechanical brake component locking device missing |3.5.1l| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Inner Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Rear Fuel system component leaking |7.2.3| | 1 |
Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Front Headlamp aim not tested |1.8.A.1c| | 1 |
Rear Position lamp not working Both |4.2.1 |a|| | 1 |
Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Fuel system component insecure |7.2.1| | 1 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Front Direction indicators not working |1.4.A.2c| | 1 |
Rear Direction indicators not working |1.4.A.2c| | 1 |
An item not tested |Manual| | 1 |
All direction indicators not working |4.4.1 |a| |ii|| | 1 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Front Brake back plate|s| securing device excessively deteriorated |3.5.1j| | 1 |
Offside Front Brake back plate|s| securing device excessively deteriorated |3.5.1j| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Rear Fuel pipe union leaking |7.2.3| | 1 |
Rear Fuel pipe leaking |7.2.3| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Exhaust engine idle speed too high |7.3.A.2a| | 1 |
Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
Emissions not tested |7.0| | 1 |
Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Floor excessively deteriorated driver`s floor forward of box section, corrosion hole. |6.2.4 |a| |i|| | 1 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Offside Front coil spring fractured |2.4.C.1a| | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
Brake has no servo assistance |3.3.B.2| | 1 |
Brake servo vacuum pipe split |3.6.C.1b| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Rear Brake clevis joint has restricted free movement |3.5.1k| | 1 |
Steering column universal joint has excessive play |2.1.5| | 1 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Front Steering system excessively tight |2.2.D.1| | 1 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
Offside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
Nearside Rear Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
Brake master cylinder/servo mounting prescribed area is inadequately repaired |3.6.C.3| | 1 |
Fuel tank leaking |7.2.3| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Rear Exhaust mounting missing |7.1.1b| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Upper Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
Offside Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Offside Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
Nearside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Headlamp switch faulty |1.7.1| | 1 |
Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Horn not working (7.7 (a) (ii)) | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
Offside Rear Hydraulic brake cylinder locking device missing |3.6.A.2d| | 1 |
Body insecure and dangerous to other road users Bonnet |6.1.B.1b| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Service brake: efficiency below requirements |3.7.B.7| | 1 |
Offside Rear Braking system leaking |3.6.A.1| | 1 |
Rear brake application uneven | 1 |
Offside Front Track rod end loose Lock nut |2.2.B.1d| | 1 |
Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
Nearside Rear Leaf spring shackle pin locking device insecurely fitted front bolt/nut |2.4.B.3b| | 1 |