Most common failures | No# failures |
---|
Headlamp aim out of alignment | 22 |
Rear brake binding | 14 |
Windscreen wiper does not clear the windscreen effectively | 13 |
Parking brake: efficiency below requirements |3.7.B.7| | 12 |
Registration plate lamp issues | 10 |
Horn not working |1.6.2a| | 8 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 8 |
Brakes imbalanced across an axle | 6 |
Offside Headlamp not working on dipped beam |1.7.5a| | 6 |
Registration plate issues | 5 |
Nearside Steering rack gaiter split |2.2.D.2d| | 5 |
Nearside Headlamp not working on main beam |1.7.5a| | 5 |
Offside Headlamp not working on main beam |1.7.5a| | 5 |
Nearside Front Wheel insecure |4.2.A.1c| | 4 |
Nearside Stop lamp not working |1.2.1b| | 4 |
Offside Stop lamp not working |1.2.1b| | 4 |
Offside Steering rack gaiter split |2.2.D.2d| | 3 |
Brake pipe excessively corroded | 3 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Rear parking brake recording little or no effort | 3 |
Service brake: efficiency below requirements |3.7.B.7| | 3 |
Nearside front brake binding |3.7.B.1| | 3 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
Offside Front Brake pipe inadequately clipped |3.6.B.1| | 3 |
Direction indicators not working |1.4.A.2c| | 3 |
Nearside Rear Stop lamp not working |1.2.1b| | 3 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 3 |
Centre Exhaust system not adequately supported |7.1.1| | 3 |
Fuel system component leaking |7.2.3| | 3 |
Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 3 |
Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Brake hose excessively deteriorated | 2 |
Offside Front Wheel insecure |4.2.A.1c| | 2 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Fuel tank leaking |7.2.3| | 2 |
Nearside Direction indicators not working |1.4.A.2c| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
Offside Front Steering rack gaiter split |2.2.D.2d| | 2 |
Offside front brake binding |3.7.B.1| | 2 |
Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 2 |
Rear Mechanical brake component has restricted free movement | 2 |
Offside Front front brake binding |3.7.B.1| | 2 |
Parking brake lever has no reserve travel |3.1.6b| | 2 |
Centre Front Brake pipe inadequately clipped |3.6.B.1| | 2 |
Nearside Rear Wheel insecure |4.2.A.1c| | 2 |
Nearside Direction indicator not working |1.4.A.2c| | 2 |
Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Fuel system component insecure |7.2.1| | 1 |
Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Rear Braking system leaking |3.6.A.1| | 1 |
Offside Front Steering rack damaged and unserviceable |2.2.C.1d| | 1 |
Nearside Lower Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Rear brake application uneven | 1 |
Offside Outer Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Outer Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Upper Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Offside rear brake juddering severely |3.7.A.5b| | 1 |
Nearside Front Anti-roll bar linkage has excessive play in a pin/bearing |2.4.G.2| | 1 |
Offside Front Anti-roll bar linkage has excessive play in a pin/bearing |2.4.G.2| | 1 |
Offside Rear Fuel pipe union leaking |7.2.3| | 1 |
Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Centre Steering pivot point has excessive play |2.2.B.1g| | 1 |
Steering pivot point has excessive play u j joint play |2.2.B.1g| | 1 |
Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced floor |7.1.1 |a| |i|| | 1 |
Rear Fuel hose insecure |6.1.3 |a| |i|| | 1 |
Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen |3.5 |a|| | 1 |
Inner Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Rear Wheel insecure |4.2.A.1c| | 1 |
Horn not working (7.7 (a)) | 1 |
Horn not working (7.7 (a) (ii)) | 1 |
Nearside front brake grabbing severely |3.7.A.2b| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Rear Fuel system component leaking |7.2.3| | 1 |
Headlamp not working on main beam |1.7.5a| | 1 |
Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front brake caliper locking device insecure |3.5.1l| | 1 |
Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength underwing upper section holed (5.3.6 (a) (i)) | 1 |
Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength underwing upper section holed (5.3.6 (a) (i)) | 1 |
Offside Front Suspension component mounting prescribed area is inadequately repaired underwing upper repaired section not welded (5.3.6 (a) (i)) | 1 |
Offside Front Lower Steering pivot point has excessive play |2.2.B.1g| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Mechanical brake component securing device missing |3.5.1i| | 1 |
Nearside rear brake grabbing severely |3.7.A.5b| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Offside Obligatory mirror missing |8.1.1| | 1 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Direction indicator not working |1.4.A.2c| | 1 |
Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Offside Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
Brake pipe inadequately supported N/S OVER REAR AXLE. |3.6.B.1| | 1 |
Front wheel bearing has excessive play BOTH FRONT. |2.5.A.3c| | 1 |
Axle king pin has excessive play in pin and/or bush adversely affecting the steering BOTH |2.5.A.3a| | 1 |
Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Battery insecure |1.9.1| | 1 |
Rear Fuel pipe leaking carberettor |7.2.3| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Windscreen washer not working | 1 |
Nearside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
Steering system fouling steering shaft fouling on engine mounting |2.2.D.2a| | 1 |
Brake pipe inadequately supported o/sf brake pies rubbing on chassis and each other |3.6.B.1| | 1 |
Headlamp aim not tested |1.8.A.1c| | 1 |
Nearside Rear Rear reflector missing |1.5.1a| | 1 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear Rear position lamp|s| missing |1.1.A.3a| | 1 |
Nearside Rear Direction indicators missing |1.4.A.2b| | 1 |
Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
Offside Front Steering column retaining device insecure |2.1.6| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded outter sill |2.4.A.3| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Steering column universal joint has excessive play |2.1.5| | 1 |
Nearside Upper Front suspension retaining device missing |2.5.A.4| | 1 |
Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
Nearside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Parking brake lever, pawl mechanism pivots or their associated mountings are insecure |3.1.4b| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Headlamp switch faulty |1.7.1| | 1 |
Electrical wiring insecure around steering shaft |1.9.2a| | 1 |
Speedometer cannot be illuminated. |6.7.3| | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Upper Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Front Anti-roll bar attachment bracket/mounting damaged and its strength is seriously reduced |2.4.G.1| | 1 |
Position lamp switch faulty |1.1.A.1| | 1 |
Nearside Rear brake drum contaminated by brake fluid |3.5.1h| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Nearside Front brake caliper has restricted free movement |3.5.1k| | 1 |
Offside Front Front suspension has excessive play in a pin or bush of an upper wishbone inner bearing |2.5.B.1a| | 1 |
Service brake: efficiency below requirements |3.7.C.1a| | 1 |
Steering wheel weakened by fractures |2.1.1| | 1 |
Offside Front Lower Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
Offside Outer Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded inner wing |2.4.A.3| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded outer sill/wing |2.4.A.3| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Nearside Rear Leaf spring anchor pin locking device insecurely fitted |2.4.B.3b| | 1 |
Offside Rear Leaf spring anchor pin retaining device insecurely fitted |2.4.B.3b| | 1 |
Offside Rear Fuel hose leaking |7.2.3| | 1 |
Fuel hose leaking |7.2.3| | 1 |
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
Nearside Front Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt split (2.1.3 (g) (ii)) | 1 |
Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing near bumpstop |5.3.6 |a| |i|| | 1 |
Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
Brake master cylinder/servo mounting prescribed area is excessively corroded (1.1.21 (e) (i)) | 1 |
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Main beam `tell-tale` not working |1.7.4c| | 1 |
Offside Rear rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Rear Wheel nut|s| loose |4.2.A.1e| | 1 |
Offside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Parking (secondary brake) on a single line braking system imbalanced across an axle Axle 1 (1.3.1 (b) (i)) | 1 |
Brake has no servo assistance |3.3.B.2| | 1 |
All position lamps not working |1.1.A.3b| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Nearside Rear Anti-roll bar linkage missing |2.4.G.1| | 1 |
Offside Rear Anti-roll bar linkage missing |2.4.G.1| | 1 |
Nearside Steering system fouling |2.2.D.2a| | 1 |
Offside Steering system fouling |2.2.D.2a| | 1 |
Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
Offside Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Front Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
Offside Front Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Brake linkage locking device insecure |3.5.1l| | 1 |
Nearside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |