MOT History from tests of diesel METROCAB MANUALs year 1999

Review the list of common METROCAB MANUAL failures below or to perform a specific mot history check on your METROCAB then use our popular KnowYourCar service

mot history

Pass percent:48.50%

(The average a diesel METROCAB MANUAL year 1999 passes without issue)

Based on:1,068 MOT Tests

Most common failures	No# failures
Parking brake: efficiency below requirements \|3.7.B.7\|	146
Headlamp aim out of alignment	126
Rear parking brake recording little or no effort	78
Registration plate lamp issues	73
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine \|7.4.B.3b\|	66
Brake pipe excessively corroded	45
Brakes imbalanced across an axle	38
Service brake: efficiency below requirements \|3.7.B.7\|	38
Windscreen wiper does not clear the windscreen effectively	29
Parking brake lever has no reserve travel \|3.1.6b\|	24
Rear brake binding	24
Offside Rear fog lamp not working \|1.3.2b\|	23
Horn not working \|1.6.2a\|	22
Offside Front position lamp\|s\| not working \|1.1.A.3b\|	19
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering \|2.5.A.3a\|	18
Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering \|2.5.A.3a\|	18
Nearside Front position lamp\|s\| not working \|1.1.A.3b\|	16
Offside Front Direction indicator not working \|1.4.A.2c\|	16
Power steering component\|s\| leaking \|2.3.3b\|	16
Exhaust has a major leak of exhaust gases \|7.1.2\|	15
Brake pedal anti-slip provision missing \|3.3.A.1b\|	15
Offside Rear Rear fog lamp not working \|1.3.2b\|	14
Nearside rear brake recording little or no effort \|3.7.B.5a\|	14
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush \|2.4.B.2\|	13
Offside Stop lamp not working \|1.2.1b\|	13
Nearside Stop lamp not working \|1.2.1b\|	12
Exhaust system not adequately supported \|7.1.1\|	12
Nearside Front Suspension arm has excessive play in a pin/bush \|2.4.G.2\|	12
Nearside Front Direction indicator not working \|1.4.A.2c\|	11
Offside Front Track rod end ball joint has excessive play \|2.2.B.1f\|	11
Rear brake application uneven	11
Offside rear brake recording little or no effort \|3.7.B.5a\|	11
Nearside Front Track rod end ball joint has excessive play \|2.2.B.1f\|	10
Centre Exhaust has a major leak of exhaust gases \|7.1.2\|	10
Offside Rear position lamp\|s\| adversely affected by the operation of another lamp \|1.1.A.3f\|	9
Steering system has excessive free play detected at the steering wheel \|steering box fitted\| \|2.2.A.1a\|	9
Nearside Side repeater not working \|1.4.A.2c\|	9
Parking brake: efficiency below requirements \|3.7.C.1b\|	9
Registration plate issues	9
Parking brake: efficiency below requirements \|3.7.D.4\|	9
Offside Side repeater not working \|1.4.A.2c\|	9
Nearside Headlamp not working on main beam \|1.7.5a\|	9
Offside Rear Direction indicator not working \|1.4.A.2c\|	8
Nearside Front Brake pipe inadequately clipped \|3.6.B.1\|	8
Offside Front Brake pipe inadequately clipped \|3.6.B.1\|	8
Nearside Front Steering pivot point has excessive play \|2.2.B.1g\|	8
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush \|2.4.B.2\|	8
Nearside Headlamp not in good working order adversely affecting beam image \|1.2.4a\|	7
Nearside Rear position lamp\|s\| adversely affected by the operation of another lamp \|1.1.A.3f\|	7
Front brake application uneven	7
Offside Rear Anti-roll bar has excessive play in a pin/bush \|2.4.G.2\|	7
Brake pedal anti-slip provision worn smooth \|3.3.A.1b\|	7
Nearside Front Lower Suspension arm has excessive play in a pin/bush \|2.4.G.2\|	7
Offside Headlamp not in good working order adversely affecting beam image \|1.2.4a\|	7
Nearside Front Shock absorber has negligible damping effect \|2.7.5\|	7
Offside Front Upper Suspension arm has excessive play in a pin/bush \|2.4.G.2\|	7
Nearside Front Shock absorber has a serious fluid leak \|2.7.3\|	7
Battery insecure \|1.9.1\|	7
Offside Front Shock absorber insecure \|2.7.2b\|	6
Brake pedal spongy \|3.3.B.1b\|	6
Nearside Rear Anti-roll bar has excessive play in a pin/bush \|2.4.G.2\|	6
Offside Headlamp not working on dipped beam \|1.7.5a\|	6
Driver`s seat insecure \|6.2.A.1\|	6
Fuel system component insecure \|7.2.1\|	6
Brake pipe inadequately clipped \|3.6.B.1\|	6
Offside Front wheel bearing has excessive play \|2.5.A.3c\|	6
Offside Front Shock absorber has negligible damping effect \|2.7.5\|	6
Nearside Headlamp not working on dipped beam \|1.7.5a\|	6
Front passenger door cannot be opened from inside the vehicle \|6.2.B.1b\|	6
Rear Exhaust system not adequately supported \|7.1.1\|	6
Steering system excessively tight \|2.2.D.1\|	6
Offside Headlamp not working on main beam \|1.7.5a\|	6
Rear Exhaust has a major leak of exhaust gases \|7.1.2\|	6
Offside Steering pivot point has excessive play \|2.2.B.1g\|	6
Offside Rear Stop lamp not working \|1.2.1b\|	5
Offside Front Shock absorber has a serious fluid leak \|2.7.3\|	5
Nearside Rear Stop lamp not working \|1.2.1b\|	5
Nearside Front Front wheel bearing has excessive play \|2.5.A.3c\|	5
Horn not loud enough to be heard by another road user \|1.6.2b\|	5
Nearside Front Steering arm has relative movement at its fixings \|2.2.B.1h\|	5
Nearside Front wheel bearing has excessive play \|2.5.A.3c\|	5
Offside Front Stub axle has excessive vertical movement between stub axle and axle beam \|2.5.A.1a\|	5
Nearside Rear Direction indicator not working \|1.4.A.2c\|	5
Nearside Front Front position lamp\|s\| not working \|1.1.A.3b\|	5
Offside Rear Brake pipe inadequately clipped \|3.6.B.1\|	5
Offside Front Front wheel bearing has excessive play \|2.5.A.3c\|	5
Nearside Steering pivot point has excessive play \|2.2.B.1g\|	5
Offside Front Brake pipe leaking \|3.6.A.1\|	5
Exhaust emits excessive smoke or vapour of any colour \|7.4.B.4\|	5
Centre Rear Statutory seat belt missing \|5.1.1\|	5
Steering box has relative movement between sector shaft and the drop arm \|2.2.B.1b\|	5
Nearside Front Upper Suspension arm has excessive play in a pin/bush \|2.4.G.2\|	5
Offside Front Lower Suspension arm has excessive play in a pin/bush \|2.4.G.2\|	5
Nearside Track rod end ball joint has excessive play \|2.2.B.1f\|	5
Fuel system component leaking \|7.2.3\|	5
Offside Rear Rear position lamp\|s\| adversely affected by the operation of another lamp \|1.1.A.3f\|	5
Nearside Front Headlamp not in good working order adversely affecting beam image \|1.2.4a\|	5
Offside Track rod end ball joint has excessive play \|2.2.B.1f\|	5
Nearside Rear position lamp\|s\| excessively deteriorated so that it is not visible from a reasonable distance \|1.1.A.3d\|	5
Front brake disc in such a condition that it is seriously weakened	4
Offside Rear Direction indicator adversely affected by the operation of another lamp \|1.4.A.2h\|	4
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	4
Offside Front Front position lamp\|s\| not working \|1.1.A.3b\|	4
Offside Front Side repeater not working \|1.4.A.2c\|	4
Offside Front Suspension arm has excessive play in a pin/bush \|2.4.G.2\|	4
Offside Headlamp aim aimed so that it dazzles other road users \|1.8.A.1a\|	4
Rear Brake pipe inadequately supported \|3.6.B.1\|	4
Steering locking device missing \|2.2.C.1g\|	4
Front Exhaust has a major leak of exhaust gases \|7.1.2\|	4
Offside Axle king pin has excessive play in pin and/or bush adversely affecting the steering \|2.5.A.3a\|	4
Offside Front Drag link end ball joint has excessive play \|2.2.B.1f\|	4
Nearside Front Lower Suspension arm has excessive play in a ball joint \|2.4.G.2\|	4
Offside Headlamp insecure \|1.7.3\|	4
Offside Front Lower Axle king pin has excessive play in pin and/or bush adversely affecting the steering \|2.5.A.3a\|	4
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	4
Exhaust emits an excessive level of metered smoke for a turbo charged engine \|7.4.B.3b\|	4
Front position lamp\|s\| not working \|1.1.A.3b\|	4
Offside Front Direction indicators not working \|1.4.A.2c\|	4
Nearside Front passenger door cannot be opened from inside the vehicle \|6.2.B.1b\|	4
Offside Headlamp aim beam image obviously incorrect \|1.8.A.1b\|	4
Steering box insecure \|2.2.B.1a\|	4
Nearside Front passenger door cannot be opened from outside the vehicle \|6.2.B.1b\|	4
Nearside Front Shock absorber insecure \|2.7.2b\|	4
Fuel pipe leaking \|7.2.3\|	4
Offside Stop lamp adversely affected by the operation of another lamp \|1.2.1f\|	3
Offside Front coil spring fractured \|2.4.C.1a\|	3
Centre Exhaust system not adequately supported \|7.1.1\|	3
Offside Front Seat belt anchorage prescribed area is excessively corroded \|5.2.6\|	3
Offside Obligatory mirror seriously damaged, affecting the rear view \|8.1.2a\|	3
Nearside Front Front suspension has excessive play in a upper suspension ball joint \|2.5.B.1a\|	3
Windscreen has damage	3
Centre Rear Seat belt has a cut which has significantly weakened the webbing \|5.2.2a\|	3
Power steering pump leaking from a failed seal \|2.3.3b\|	3
Nearside Front Sub-frame has excessive play in a pin/bush \|2.4.G.2\|	3
Offside Rear rear brake recording little or no effort \|3.7.B.5a\|	3
Nearside Rear rear brake recording little or no effort \|3.7.B.5a\|	3
Nearside Front Brake pipe kinked \|3.6.B.2b\|	3
Offside Stop lamp excessively damaged so that it is not visible from a reasonable distance \|1.2.1d\|	3
Power steering component\|s\| leaking from a failed seal \|2.3.3b\|	3
Offside Drag link end ball joint has excessive play \|2.2.B.1f\|	3
Driver`s door cannot be opened from inside the vehicle \|6.2.B.1b\|	3
Brake cable has wires broken and is significantly weakened \|3.5.1b\|	3
Offside Rear fog lamp excessively damaged so that it is not visible from a reasonable distance \|1.3.2d\|	3
Bonnet cannot be secured in the closed position \|8.4.1\|	3
Horn sounds harsh or grating \|1.6.2e\|	3
Nearside Headlamp insecure \|1.7.3\|	3
Offside Front Lower Suspension arm has excessive play in a ball joint \|2.4.G.2\|	3
Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	3
Rear fog lamp tell tale not working \|1.3.1b\|	3
Nearside Front Direction indicator excessively damaged so that it is not visible from a reasonable distance \|1.4.A.2e\|	3
Offside Front Headlamp not in good working order adversely affecting beam image \|1.2.4a\|	3
Centre Stop lamp not working \|1.2.1b\|	3
Hazard warning switch faulty \|1.4.B.1d\|	3
Steering locking device insecure \|2.2.C.1g\|	3
Nearside Rear Direction indicator adversely affected by the operation of another lamp \|1.4.A.2h\|	3
Offside Front Lower Steering pivot point has excessive play \|2.2.B.1g\|	3
Nearside Front Side repeater not working \|1.4.A.2c\|	3
Nearside Front Headlamp not working on dipped beam \|1.7.5a\|	3
Brake hose has insufficient room to move	3
Offside Steering arm has relative movement at its fixings \|2.2.B.1h\|	3
Offside Rear position lamp\|s\| excessively damaged so that it is not visible from a reasonable distance \|1.1.A.3d\|	3
Steering pivot point has excessive play \|2.2.B.1g\|	3
Centre Brake cable has wires broken and is significantly weakened \|3.5.1b\|	3
Brake hose excessively deteriorated	3
Steering box has a significant oil leak \|2.2.D.2e\|	3
Nearside Front Shock absorber has an excessively worn shock absorber pivot \|2.7.4\|	3
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	3
Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	3
Offside Outer Front Track rod end ball joint has excessive play \|2.2.B.1f\|	3
Fuel tank leaking \|7.2.3\|	3
Stop lamp remains on when the brakes are released	3
Nearside Front coil spring fractured \|2.4.C.1a\|	3
Brake hose damaged	3
Offside Front Suspension spring mounting prescribed area is excessively corroded \|2.4.A.3\|	3
Nearside Front suspension has excessive play in a lower suspension ball joint \|2.5.B.1a\|	2
Nearside Front Steering component is not secure to the vehicle structure \|2.2.B.1a\|	2
Offside Rear fog lamp adversely affected by the operation of another lamp \|1.3.2f\|	2
Nearside Rear Leaf spring shackle pin excessively loose in its bracket \|2.4.B.3a\|	2
Offside Rear Leaf spring eye defective \|shackle\| \|2.4.B.1b\|	2
Nearside rear brake excessively fluctuating \|3.7.B.3\|	2
Offside rear brake excessively fluctuating \|3.7.B.3\|	2
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	2
Nearside Front Seat belt anchorage prescribed area is excessively corroded \|5.2.6\|	2
Service brake: efficiency below requirements \|3.7.C.1a\|	2
Nearside Front Front suspension has excessive play in a lower suspension ball joint \|2.5.B.1a\|	2
Offside Front Front suspension has excessive play in a lower suspension ball joint \|2.5.B.1a\|	2
Brake servo vacuum pipe deteriorated \|3.6.C.1b\|	2
Nearside Rear Leaf spring anchor pin retaining device insecurely fitted \|2.4.B.3b\|	2
Nearside Front position lamp\|s\| not in good working order \|function impaired\| \|1.1.4a\|	2
Offside Rear Statutory seat belt missing \|5.1.1\|	2
Offside Front Lower Axle swivel joint has excessive play \|2.5.A.3b\|	2
Offside Front Side repeater missing \|1.4.A.2b\|	2
Offside Front Sub-frame has excessive play in a pin/bush \|2.4.G.2\|	2
Nearside Front Front position lamp\|s\| excessively deteriorated so that it is not visible from a reasonable distance \|1.1.A.3d\|	2
Offside Rear Rear position lamp\|s\| not working \|1.1.A.3b\|	2
Offside Rear Leaf spring to axle securing bolt insecure \|2.4.B.7b\|	2
An item not tested \|Manual\|	2
Nearside Front Brake pipe inadequately supported \|3.6.B.1\|	2
Offside Front wheel bearing rough when rotated \|2.5.A.2\|	2
Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt \|2.2.C.1c\|	2
Brake pedal anti-slip provision incomplete \|3.3.A.1b\|	2
Nearside Front Brake hose bulging under pressure \|3.6.B.3\|	2
Front Sub-frame has excessive play in a pin/bush \|2.4.G.2\|	2
Windscreen wiper blade insecure	2
Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement \|2.4.B.2\|	2
Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush \|2.4.B.2\|	2
Offside Rear Leaf spring fractured \|2.4.B.1a\|	2
Offside Front Steering pivot point has excessive play \|2.2.B.1g\|	2
Offside Front brake caliper leaking \|3.6.A.1\|	2
Nearside Rear wheel bearing has excessive play \|2.6.2\|	2
Brake servo leaking \|3.6.C.1c\|	2
Nearside Front Ball joint has excessive play \|2.2.B.1f\|	2
Nearside Inner Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt \|2.2.C.1c\|	2
Nearside Front Steering system has a road wheel fouling a part of the vehicle \|2.2.D.2a\|	2
Nearside Parking brake recording little or no effort \|3.7.D.3a\|	2
Offside Front Statutory seat belt missing \|5.1.1\|	2
Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	2
Offside Front Headlamp not working on dipped beam \|1.7.5a\|	2
Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	2
Nearside Front Lower Axle king pin has excessive play in pin and/or bush adversely affecting the steering \|2.5.A.3a\|	2
Brake performance not tested \|3.7.A.1\|	2
Nearside Front Direction indicator incomplete \|1.5.A1b\|	2
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	2
Nearside Rear Statutory seat belt missing \|5.1.1\|	2
Hazard warning lamps not flashing in phase, with ignition on \|1.4.B.1f\|	2
Nearside Rear Rear position lamp\|s\| adversely affected by the operation of another lamp \|1.1.A.3f\|	2
Nearside rear brake grabbing severely \|3.7.A.5b\|	2
Nearside Headlamp excessively damaged so that the light output is severely reduced \|1.7.5a\|	2
Nearside Front Lower Steering pivot point has excessive play \|2.2.B.1g\|	2
Offside Front Front suspension locking device missing \|2.5.A.4\|	2
Offside Front Lower Shock absorber insecure \|2.7.2b\|	2
Nearside Rear Brake pipe inadequately clipped \|3.6.B.1\|	2
Offside Front Lower Axle swivel joint has excessive play in a swivel pin \|2.5.A.3b\|	2
Offside Front Brake pipe fouled by moving parts \|3.6.B.2a\|	2
Offside Rear Direction indicators not working \|1.4.A.2c\|	2
Nearside Inner Track rod end ball joint has excessive play \|2.2.B.1f\|	2
Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush \|2.4.G.2\|	2
Nearside Front Upper Suspension spring mounting prescribed area is excessively corroded \|2.4.A.3\|	2
Offside Front Upper Suspension spring mounting prescribed area is excessively corroded \|2.4.A.3\|	2
Centre Stop lamp excessively deteriorated so that it is not visible from a reasonable distance \|1.2.1d\|	2
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement \|7.2.4b\|	2
Nearside Headlamp aim beam image obviously incorrect \|1.8.A.1b\|	2
Rear fog lamp not working \|1.3.2b\|	2
Nearside Front Lower Axle swivel joint has excessive play in a swivel pin \|2.5.A.3b\|	2
Offside Front suspension retaining device missing \|2.5.A.4\|	2
Offside Rear Fuel pipe leaking \|7.2.3\|	2
rear brake recording little or no effort \|3.7.B.5a\|	2
Offside Brake cable has restricted free movement \|3.5.1k\|	2
Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement \|2.4.B.2\|	2
Nearside Front suspension has excessive play in a upper suspension ball joint \|2.5.B.1a\|	2
Nearside Rear Braking system leaking \|3.6.A.1\|	2
Nearside Rear Rear fog lamp not working \|1.3.2b\|	2
Nearside Front Upper Shock absorber insecure \|2.7.2b\|	2
Nearside Front wheel bearing rough when rotated \|2.5.A.2\|	2
Nearside Stop lamp adversely affected by the operation of another lamp \|1.2.1f\|	2
Nearside Front Lower Shock absorber has an excessively worn bush \|2.7.4\|	2
Brake hydraulic reservoir cap missing \|3.6.G.1a\|	2
Braking system leaking \|3.6.A.1\|	2
Nearside Front Suspension arm attachment bracket/mounting insecure \|2.4.G.1\|	2
Offside Front Brake pipe kinked \|3.6.B.2b\|	2
Offside Rear Seat belt locking mechanism does not secure or release \|5.2.5a\|	2
Offside Front Shock absorber has an excessively worn bush \|2.7.4\|	2
Steering column movement between the shaft and steering wheel \|2.1.2b\|	2
Offside Front Ball joint has excessive play \|2.2.B.1f\|	2
Nearside Front suspension has excessive movement at a wishbone pin or bush \|2.5.A.1c\|	2
Offside Front suspension has excessive movement at a wishbone pin or bush \|2.5.A.1c\|	2
Offside Front Upper Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	2
Offside Front Braking system leaking \|3.6.A.1\|	2
Power steering component\|s\| leaking from a failed joint \|2.3.3b\|	2

We get to these numbers by trawling through over 1 billion MOT test results since 2004 and crunched the numbers. We remove anything to do with Tyres, as they are model independent and group together common non-model specific issues. We are trying to get to a picture of what models have what issues.

Please note: We take the data from the DVSA. This data is raw and can contain typos and spelling mistakes that garages may have entered while recording a MOT result. Specifically miss-match on names of models and makes. We are constantly cleaning the data so bear with the odd issue.

Got suggestions? We’re improving this section all the time. If you have any suggestions, please let us know.

MOT History from tests of diesel METROCAB MANUALs year 1999

Find us on Facebook