Most common failures | No# failures |
---|
Headlamp aim out of alignment | 16 |
Registration plate lamp issues | 12 |
Windscreen wiper does not clear the windscreen effectively | 6 |
Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 5 |
Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 4 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 4 |
Brake pipe excessively corroded | 4 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 4 |
Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 3 |
Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 3 |
Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 3 |
Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 3 |
Electronic stability control warning lamp indicates a fault (7.12 (e)) | 3 |
Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 3 |
Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
Registration plate issues | 2 |
Anti-lock braking system warning lamp indicates an ABS fault | 2 |
Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
Nearside Front Shock absorbers has a serious fluid leak | 2 |
Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 2 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
Exhaust particulate filter missing where one was fitted as standard |7.1.3| | 2 |
Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength emergency exit step (5.3.6 (a) (i)) | 1 |
Nearside Rear Seat belt not functioning as intended row (7.1.2 (c)) | 1 |
Central Rear Seat belt not functioning as intended row (7.1.2 (c)) | 1 |
Offside Rear Inner Seat belt not functioning as intended (7.1.2 (c)) | 1 |
Nearside Front Headlamp has a product on the lens so that the light output is severely reduced condensated (4.1.4 (b)) | 1 |
Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Front Front position lamp|s| not working side light |1.1.A.3b| | 1 |
Nearside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
Offside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
Offside Stop lamp|s| remains on when the brakes are released |4.3.2 |a| |iii|| | 1 |
Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Offside Rear Rear fog lamp does not emit a steady red light LIGHT UNIT BROKEN (4.5.4 (a)) | 1 |
Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Nearside Front Upper Body has an unsafe modification Body support bracket insecure. (6.2.1 (d) (i)) | 1 |
Nearside Front Seat belt not functioning as intended sticking doesnt come out (7.1.2 (c)) | 1 |
Seat belt not functioning as intended rear row 2nd from the right stuck in doesnt come out (7.1.2 (c)) | 1 |
Offside Front Seat belt not functioning as intended seat behind drivers doesnt plug in (7.1.2 (c)) | 1 |
Service brake effort inadequate at a wheel both rear handbrake efforts (1.2.1 (a) (i)) | 1 |
Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
Suspension arm ball joint excessively worn both front (5.3.4 (a) (i)) | 1 |
Leaf spring to axle fixing bolt insecure all rear (5.3.1 (a) (i)) | 1 |
Electrical wiring likely to drag on the ground (4.11 (a) (iii)) | 1 |
Vehicle structure strengthening plate or fastening so insecure that structural rigidity is seriously reduced boot floor holed and corroded at both sides (6.1.1 (b) (ii)) | 1 |
Nearside Rear reflector defective or damaged by more than 50% of the reflecting surface (4.8.1 (a) (ii)) | 1 |
Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Offside Stop lamp not working |1.2.1b| | 1 |
Offside Rear fog lamp not working |1.3.2b| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Front Track rod end ball joint has excessive play both side (2.1.3 (b) (i)) | 1 |
Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Rear Direction indicator incorrect colour both left and right side |4.4.3 |a|| | 1 |
Windscreen washer not working | 1 |
Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Windscreen in an unacceptable condition (3.2 (c) (i)) | 1 |
Emissions not tested Due to E.M.L (8.2.2.2 (e)) | 1 |
Nearside Front Steering rack has excessive free play detected at the steering wheel (steering rack fitted) Steering arm (2.3 (a) (i)) | 1 |
Offside Front Steering rack has excessive free play detected at the steering wheel (steering rack fitted) Steering arm (2.3 (a) (i)) | 1 |
Nearside Side repeater lens defective such that the emitted light is adversely affected (4.4.1 (b) (ii)) | 1 |
Offside Side repeater incorrect colour (4.4.3 (a)) | 1 |
Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
Nearside Inner Steering linkage ball joint has excessive play rack end (2.1.3 (b) (i)) | 1 |
Nearside Rear Inner Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Prop shaft likely to become detached (6.1.7 (a) (ii)) | 1 |
Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Front Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Nearside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
Nearside Stop lamp|s| light intensity significantly reduced |4.3.3 |a| |ii|| | 1 |
Rear brake binding | 1 |
Rear brake application uneven | 1 |
Rear rear brakes release unevenly |3.7.B.4| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Rear position lamp|s| not working side marker |1.1.A.3b| | 1 |
Nearside Side repeater not working |1.4.A.2c| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Rear outline marker lamp|s| not working |1.1.B.1c| | 1 |
Offside All outline marker lamps not working |1.1.B.1c| | 1 |
Speed limiter plate missing |6.5.A.1a| | 1 |
Upper All outline marker lamps not working |4.2.1 |a|| | 1 |
Offside Rear Outline marker lamp not working |4.2.1 |a|| | 1 |
Offside Rear reflector missing |4.8.2 |a| |ii|| | 1 |
Exhaust on a vehicle fitted with a diesel particulate filter emits visible smoke of any colour |8.2.2.2 |d|| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Headlamp aim projected beam image is obviously incorrect No Pattern (4.1.2 (c)) | 1 |
Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Windscreen in an unacceptable condition (3.2 (c) (i)) | 1 |
Nearside Front Anti-roll bar linkage ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Front Anti-roll bar pin or bush excessively worn Bush (5.3.4 (a) (i)) | 1 |
Offside Front Anti-roll bar pin or bush excessively worn Bush (5.3.4 (a) (i)) | 1 |
Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
Nearside Front Anti-roll bar linkage insecurely attached |5.3.3 |a| |i|| | 1 |
Rear Body has a sharp edge caused by damage step |6.1.C.1| | 1 |
Nearside Rear Body has a sharp edge caused by damage lamp |6.1.C.1| | 1 |
Nearside Rear Seat belt locking mechanism does not secure or release buckle missing |5.2.5a| | 1 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Seat belt retracting mechanism defective |5.2.5b| | 1 |
Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Central Front Power steering pipe/hose leaking |2.1.5 |a|| | 1 |
Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
Nearside Rear Rear reflector defective or damaged by more than 50% of the reflecting surface |4.8.1 |a| |ii|| | 1 |
Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
Nearside Front Lower Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Offside Front Lower Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Hazard warning switch inoperative missing (4.4.2 (a) (ii)) | 1 |
Horn not working (7.7 (a) (ii)) | 1 |
Headlamp not working on dipped beam Both (4.1.1 (a) (ii)) | 1 |
Body component damaged and likely to cause injury front brill at both headlamp corners has popped out both sides (6.2.1 (a) (i)) | 1 |
Offside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen washer hose to short on wiper arm (3.5 (a)) | 1 |
Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt is off steering rack end (2.1.3 (g) (ii)) | 1 |
Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength door step (5.3.6 (a) (i)) | 1 |
Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Brakes imbalanced across an axle | 1 |
Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
Offside Front Side repeater incorrect colour door mirror |4.4.3 |a|| | 1 |
Nearside Rear Rear reflector likely to become detached (4.8.1 (b) (ii)) | 1 |
Exhaust silencer insecure (8.1.1 (b) (i)) | 1 |
Offside Rear Anti-roll bar linkage pin or bush excessively worn drop link (5.3.4 (a) (i)) | 1 |
Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Brake hose damaged | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Offside Front Lower Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Rear Anti-roll bar pin or bush excessively worn D BUSHES (5.3.4 (a) (i)) | 1 |
Offside Rear Anti-roll bar pin or bush excessively worn D BUSHES (5.3.4 (a) (i)) | 1 |
Nearside Rear Anti-roll bar pin or bush excessively worn O BUSH (5.3.4 (a) (i)) | 1 |
Offside Rear Anti-roll bar pin or bush excessively worn O BUSH (5.3.4 (a) (i)) | 1 |
Offside Rear Body panel damaged and likely to cause injury TAIL LIGHT (6.2.1 (a) (i)) | 1 |
Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Offside Front Shock absorbers has a serious fluid leak | 1 |
Central Prop shaft bearing likely to break up |6.1.7 |b| |ii|| | 1 |
Nearside Front Steering arm fractured |2.1.3 |c| |i|| | 1 |
Nearside Front All position lamps not working |1.1.A.3b| | 1 |
Nearside Lower All position lamps not working |1.1.A.3b| | 1 |
Offside Lower All position lamps not working |1.1.A.3b| | 1 |
Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt Both front outer (6.1.7 (g) (ii)) | 1 |
Trailer electrical socket likely to become detached (4.10 (a) (ii)) | 1 |
Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
Front brake disc in such a condition that it is seriously weakened | 1 |
Emissions not tested |7.4.B.1| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Rear Air suspension unit totally deflated all four air bags |2.4.D.1a| | 1 |
Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Offside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
Emissions not tested |7.3.A.1| | 1 |
Offside Front Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Rear Leaf spring to axle fixings loose to the extent that relative movement is visible stretched/loose U bolts |5.3.1 |a| |ii|| | 1 |
Offside Rear reflector defective or damaged by more than 50% of the reflecting surface (4.8.1 (a) (ii)) | 1 |
Offside Body panel damaged and likely to cause injury area of lower sill (6.2.1 (a) (i)) | 1 |
Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
Offside Rear Rear outline marker lamp|s| not working |1.1.B.1c| | 1 |
Seat belt retracting mechanism defective 4 seats on very rear |7.1.2 |e|| | 1 |
Nearside Windscreen wiper not working can not test wiper blade |3.4 |a|| | 1 |
Offside Outline marker lamp not working middle |4.2.1 |a|| | 1 |
Brake hydraulic reservoir cap missing |1.1.10 |e|| | 1 |
Offside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
Nearside Rear Braking system leaking (1.1.3 (d)) | 1 |
Nearside Front Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |