| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 38 |
| Registration plate lamp issues | 36 |
| Windscreen wiper does not clear the windscreen effectively | 26 |
| Parking brake: efficiency below requirements |3.7.B.7| | 21 |
| Parking brake lever has no reserve travel |3.1.6b| | 12 |
| Brake pipe excessively corroded | 11 |
| Registration plate issues | 8 |
| Offside Rear fog lamp not working |1.3.2b| | 6 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 6 |
| Nearside Rear Stop lamp not working |1.2.1b| | 6 |
| Nearside Stop lamp not working |1.2.1b| | 5 |
| Brakes imbalanced across an axle | 5 |
| Windscreen has damage | 5 |
| Rear parking brake recording little or no effort | 5 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Offside Rear Stop lamp not working |1.2.1b| | 4 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
| Front brake disc in such a condition that it is seriously weakened | 4 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 4 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Body has a sharp edge caused by damage |6.1.C.1| | 3 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Fuel cap/sealing device missing |7.2.4a| | 3 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Rear brake binding | 3 |
| Brake hose excessively deteriorated | 3 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 2 |
| Front Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Battery insecure |1.9.1| | 2 |
| Nearside Front Windscreen wiper blade missing |8.2.2| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Horn not working |1.6.2a| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Body has a sharp edge caused by corrosion N/S/R WING |6.1.C.1| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Passenger`s seat insecure |6.2.A.1| | 1 |
| Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| brake disc in such a condition that it is seriously weakened |3.5.1i| | 1 |
| Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Outline marker lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Outline marker lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill |6.2.2 |d| |i|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Front Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
| Nearside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Brake pipe leaking on a hydraulic braking system front/rear (1.1.11 (b) (ii)) | 1 |
| Offside Brake pipe excessively damaged front/rear (1.1.11 (c)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Parking brake lever inoperative (1.1.6 (d)) | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Power steering pump drive system defective |2.3.6| | 1 |
| Nearside Outline marker lamp not working |4.2.1 |a|| | 1 |
| Offside Outline marker lamp not working |4.2.1 |a|| | 1 |
| Emissions not tested Exhaust blow |8.2.1.2 |d|| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Front wheel bearing has excessive play both
|2.5.A.3c| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| All outline marker lamps not working |1.1.B.1c| | 1 |
| Offside Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Position lamp adversely affected by the operation of another lamp All front and rear lights affected by others- maybe earth problem (4.2.3 (c)) | 1 |
| Horn sound not in accordance with requirements (7.7 (c)) | 1 |
| Suspension component mounting prescribed area is inadequately repaired outer sills @ all rear spring mountings (5.3.6 (a) (i)) | 1 |
| Offside Rear Brake prescribed area is excessively corroded @ flexi brake pipe (1.1.21 (e) (i)) | 1 |
| Fuel hose leaking @ tank (6.1.3 (b) (i)) | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Steering system fouling |2.2.D.2a| | 1 |
| Offside Steering system fouling |2.2.D.2a| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Brake hose has insufficient room to move | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Headlamp are incorrectly positioned adjusted (4.1.4 (a)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Outer Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Offside Outer Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill (6.1.1 (c) (i)) | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Electronic stability control warning lamp indicates a fault |7.12 |e|| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Nearside Body component damaged and likely to cause injury mirror indicator lense damaged, sharp |6.2.1 |a| |i|| | 1 |
| Horn sounds harsh or grating |1.6.2e| | 1 |
| Emissions not tested |7.0| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front Headlamp lens seriously defective both (4.1.1 (b) (ii)) | 1 |
| Nearside Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Position lamp missing |4.2.1 |a|| | 1 |
| Offside Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
| Nearside Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Offside Obligatory mirror is incapable of being adjusted to provide an adequate view to the rear |8.1.2b| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting bolt missing |2.4.G.1| | 1 |
| Offside Front position lamp|s| not working side marker |1.1.A.3b| | 1 |
| Nearside Rear position lamp|s| not working side marker |1.1.A.3b| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Rear position lamp|s| incorrect colour lamp cracked |1.1.A.3e| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Suspension arm locating pin insecure |2.4.G.3a| | 1 |
| Leaf spring shackle bracket loose |2.4.B.6a| | 1 |
| Brake pedal anti-slip provision loose |3.3.A.1b| | 1 |
| Electrical wiring insecure |1.9.2a| | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Front Windscreen wiper blade missing |8.2.2| | 1 |
| Rear Loading door cannot be secured in the closed position |6.4.1| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Obligatory mirror insecure (3.3 (b) (ii)) | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Offside Outer Vehicle structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired sev places along cill (6.2.2 (d) (ii)) | 1 |
| Offside Front Inner Vehicle structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired step/cill (6.2.2 (d) (ii)) | 1 |
| Nearside Outer Vehicle structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired cill (6.2.2 (d) (ii)) | 1 |
| Offside Rear Outer Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting cill (6.2.2 (d) (i)) | 1 |
| Nearside Rear Outer Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting cill (6.2.2 (d) (i)) | 1 |
| Offside Front Seat belt stitching not secure |5.2.2b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside All position lamps not working |1.1.A.3b| | 1 |
| Offside All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Leaf spring longitudinally displaced |2.4.B.1d| | 1 |
| Offside Rear Leaf spring longitudinally displaced |2.4.B.1d| | 1 |
| Nearside Rear Leaf spring splayed and action impaired |2.4.B.1c| | 1 |
| Offside Rear Leaf spring splayed and action impaired |2.4.B.1c| | 1 |
| Front Body has a sharp edge caused by corrosion bonnet |6.1.C.1| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion wheel arch |6.1.C.1| | 1 |
| Service brake: efficiency below requirements |3.7.D.4| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill |6.1.1 |c| |i|| | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Towbar component insecure |6.6.1| | 1 |
| Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn D-bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn D-bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |