| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 7 |
| Registration plate lamp issues | 5 |
| Offside Front coil spring fractured |2.4.C.1a| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Brake pipe excessively corroded | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Nearside Front coil spring fractured |2.4.C.1a| | 2 |
| Brake hose excessively deteriorated | 2 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Registration plate issues | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Rear brake application uneven | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Brake hose twisted |3.6.B.4c| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Offside Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Rear Stop lamp|s| adversely affected by the operation of another lamp |4.3.3 |b|| | 1 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Lower Front suspension locking device ineffective frpmt suspension bush |2.5.A.4| | 1 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Rear Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Emissions not tested |7.0| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Suspension arm rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Horn not working |1.6.2a| | 1 |