| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 42 |
| Registration plate lamp issues | 24 |
| Headlamp aim out of alignment | 23 |
| Parking brake: efficiency below requirements |3.7.B.7| | 15 |
| Nearside Stop lamp not working |1.2.1b| | 11 |
| Offside Stop lamp not working |1.2.1b| | 10 |
| Offside Rear fog lamp not working |1.3.2b| | 9 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 9 |
| Brake pipe excessively corroded | 8 |
| Parking brake lever has no reserve travel |3.1.6b| | 8 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 6 |
| Brakes imbalanced across an axle | 5 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Nearside Rear Stop lamp not working |1.2.1b| | 4 |
| Rear brake binding | 4 |
| Windscreen washer not working | 4 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 4 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 4 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 4 |
| Registration plate issues | 4 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 3 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 3 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Side repeater not working |1.4.A.2c| | 3 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 3 |
| Windscreen has damage | 3 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 3 |
| Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Front brake application uneven | 2 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Brake cable knotted |3.5.1b| | 1 |
| Fuel system component leaking under bonnet ( diesel filler pipes ) (6.1.3 (b) (i)) | 1 |
| Brake load sensing valve seized but ABS functioning (1.1.17 (c) (i)) | 1 |
| Nearside Rear Position lamp not working side |4.2.1 |a|| | 1 |
| Nearside Rear Position lamp not working top side light |4.2.1 |a|| | 1 |
| Offside Position lamp not working marker light x 2 |4.2.1 |a|| | 1 |
| Brake performance not tested due to brake pipe failure (1.2.1 (g)) | 1 |
| Offside Outline marker lamp not working |4.2.1 |a|| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Bonnet seriously at risk of opening inadvertently (3.1 (b) (ii)) | 1 |
| Offside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Rear Brake pipe likely to become detached or damaged front to rear x 2 |1.1.11 |d| |ii|| | 1 |
| Offside Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
| Nearside Headlamp lens seriously defective |4.1.1 |b| |ii|| | 1 |
| Offside Headlamp lens seriously defective |4.1.1 |b| |ii|| | 1 |
| Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn in excess of 3mm lift (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn in excess of 3mm lift (5.3.4 (a) (i)) | 1 |
| Electronic stability system warning lamp does not illuminate |3.4.1b| | 1 |
| Offside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Leaf spring main leaf fractured (5.3.1 (b) (ii)) | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Brake master cylinder leaking (1.1.10 (b) (ii)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Outline marker lamp missing (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Outline marker lamp missing (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Bumper insecure arch |6.1.4 |a| |i|| | 1 |
| Nearside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Seat belt damaged (7.1.2 (b) (i)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Rear Leaf spring fractured (5.3.1 (b) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases tail pipe |7.1.2| | 1 |
| Nearside All position lamps not working |1.1.A.3b| | 1 |
| Centre Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Windscreen wiper blade insecure | 1 |
| Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Fuel system component leaking |7.2.3| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Exhaust fumes causing a danger to health of persons on board (6.1.2 (b) (ii)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
| Offside Front Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Outline marker lamp not working |4.2.1 |a|| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Service brake efficiency less than 50% of the required value |1.2.2 |a| |ii|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Front Drag link end ball joint worn to the extent there is a serious risk of detachment o/s front drag link as excessive play in both ends (2.1.3 (b) (ii)) | 1 |
| Nearside Outline marker lamp not working n/s fist side marker inop (4.2.1 (a) (ii)) | 1 |
| Offside Front Seat belt webbing significantly weakened cut greater than 4mm o/s front seat belt cut on edge (7.1.2 (b)) | 1 |
| Central Front Direction indicator light intensity significantly reduced both front indicators showing white light (4.4.3 (a)) | 1 |
| Rear Direction indicator light intensity significantly reduced n/s rear indicator showing white light (4.4.3 (a)) | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Nearside Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Offside Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Rear Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Leaf spring fractured Small portion of 3rd leaf missing (5.3.1 (b) (i)) | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Front All position lamps not working |4.2.1 |a|| | 1 |
| Fuel cap/sealing device missing missing (6.1.3 (b) (i)) | 1 |
| Offside Front Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
| Nearside Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Nearside Front Side repeater incomplete |1.5.A1b| | 1 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Front Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Windscreen wiper blade missing (3.4 (b) (ii)) | 1 |
| Rear fog lamp switch inoperative |4.5.3 |a| |ii|| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Brake cable locking device missing |3.5.1l| | 1 |
| Braking system leaking front to rear pipe |3.6.A.1| | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside All outline marker lamps not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp showing white light to the rear side marker (4.2.3 (a) (ii)) | 1 |
| Rear brake application uneven | 1 |
| Rear Stop lamp(s) remains on when the brakes are released (4.3.2 (a) (iii)) | 1 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn bush is part of the anti roll bar |5.3.4 |a| |i|| | 1 |
| Offside Rear Lower Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Rear Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Rear Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Brake cable damaged handbrake cable has been rubbing on exhaust and has frayed will require replacement and exhaust will require adjustment risk of cable snapping when vehicle is parked |1.1.15 |a|| | 1 |
| Offside Front Lower Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting step/ body mount area |6.2.2 |d| |i|| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear Direction indicators adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Rear Direction indicators adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Rear Rear position lamp|s| not working TAIL LIGHT |1.1.A.3b| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Lower Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Front Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
| Brake cable locking device insecure |3.5.1l| | 1 |
| Electrical wiring inadequately supported |1.9.2a| | 1 |
| Nearside Rear Upper Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Upper Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
| All position lamps not working side markers o/s and n/s |1.1.A.3b| | 1 |
| Stop lamp not working all upper lights |1.2.1b| | 1 |