| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 29 |
| Windscreen wiper does not clear the windscreen effectively | 23 |
| Parking brake: efficiency below requirements |3.7.B.7| | 11 |
| Registration plate lamp issues | 8 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 7 |
| Brake pipe excessively corroded | 7 |
| Rear parking brake recording little or no effort | 6 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Brake hose excessively deteriorated | 3 |
| Registration plate issues | 3 |
| Windscreen has damage | 3 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Horn not working (7.7 (a)) | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Rear brake disc in such a condition that it is seriously weakened | 3 |
| Brakes imbalanced across an axle | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Offside Headlamp insecure |1.7.3| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Power steering pump drive system defective |2.3.6| | 2 |
| Front brake excessively fluctuating | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Brake hose connection leaking on an air braking system (1.1.12 (c) (i)) | 2 |
| Rear Exhaust system insecure (6.1.2 (a)) | 2 |
| Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Front Exhaust has a major leak of exhaust gases down pipe |7.1.2| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Lower Steering column universal joint has excessive play |2.1.5| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Nearside Front Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Front Brake cable has wires broken and is significantly weakened to rear |3.5.1b| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Rear fog lamp not in good working order |not working| |1.1.6b| | 1 |
| Rear fog lamp tell tale inoperative |1.1.6e| | 1 |
| Rear Electrical wiring likely to touch hot or rotating parts differential |4.11 |a| |iii|| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Front Front outline marker lamp|s| not working |1.1.B.1c| | 1 |
| Front Electrical wiring insecure |1.9.2a| | 1 |
| Front Electrical wiring inadequately supported |1.9.2a| | 1 |
| Offside Front Leaf spring anchor pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Fuel system component leaking |7.2.3| | 1 |
| Fuel system component leaking up at pump area (6.1.3 (b) (i)) | 1 |
| Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Leaf spring main leaf fractured (5.3.1 (b) (ii)) | 1 |
| Nearside Rear Leaf spring main leaf fractured (5.3.1 (b) (ii)) | 1 |
| Nearside Rear Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Brake insecure brake accumulator not fully secure (1.1.21 (c)) | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Stop lamp not working ALL |1.2.1b| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Rear Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Brake load sensing valve seized but ABS functioning (1.1.17 (c) (i)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
| Exhaust emissions exceed manufacturer`s specified limit |8.2.2.2 |a|| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Horn not working |1.6.2a| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Stop lamp adversely affected by the operation of another lamp on all the time |1.2.1f| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Brake pipe at imminent risk of failure or fracture corroding and weeping (1.1.11 (a)) | 1 |
| Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt both sides split (2.1.3 (g) (ii)) | 1 |
| Offside Front Drag link end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting fractured (5.3.3 (b) (ii)) | 1 |
| Rear Exhaust emissions likely to be affected by an exhaust leak middle box (8.2.2.1 (b)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Behind wheel (6.2.2 (d) (i)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Behind wheel (6.2.2 (d) (i)) | 1 |
| Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction Sun visor (3.1 (a) (ii)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions unable to be completed (8.2.2.2 (e)) | 1 |
| Offside Floor excessively deteriorated Step (6.2.4 (a) (i)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Inappropriate repair x2 (6.2.2 (d) (i)) | 1 |
| Offside Rear Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Nearside Rear Brake back plate|s| securing device excessively deteriorated |3.5.1j| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Nearside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Fuel system component leaking (6.1.3 (b) (i)) | 1 |
| Nearside Lower Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Power steering pipe/hose excessively corroded to steering box |2.1.5 |g| |i|| | 1 |
| Nearside Rear Power steering pipe/hose excessively corroded 2 pipes from to resevoir |2.1.5 |g| |i|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Lower Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear Braking system leaking |1.1.3 |d|| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Front Exhaust has a major leak of exhaust gases down pipe |6.1.2 |a|| | 1 |
| Nearside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Centre Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside An item not tested |Manual| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Front Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt insecure |2.4.G.2| | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear fog lamp adversely affected by the operation of another lamp |1.3.2f| | 1 |
| Nearside All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Offside Front Upper Outline marker lamp not working |4.2.1 |a|| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Rear fog lamp switch insecure |1.3.1a| | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Offside Rear Anti-roll bar insecure |2.4.G.1| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Hydraulic fluid leaking continuously posing a serious risk to road safety (8.4.1 (a) (ii)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Nearside Rear Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting fractured (5.3.3 (b) (ii)) | 1 |
| Offside Rear Anti-roll bar pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Rear Leaf spring fractured (5.3.1 (b) (i)) | 1 |
| Nearside Rear Lower Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Obligatory mirror insecure (3.3 (b) (ii)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Rear Upper Outline marker lamp not working both sides (4.2.1 (a) (ii)) | 1 |
| Offside Rear Body component insecure wheel arch (6.2.1 (a) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |