Most common failures | No# failures |
---|
Headlamp aim out of alignment | 31 |
Registration plate lamp issues | 21 |
Parking brake: efficiency below requirements |3.7.B.7| | 20 |
Brake pipe excessively corroded | 15 |
Windscreen wiper does not clear the windscreen effectively | 11 |
Brake load sensing valve linkage seized |3.6.E.3| | 8 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 6 |
Rear parking brake recording little or no effort | 6 |
Registration plate issues | 5 |
Service brake: efficiency below requirements |3.7.B.7| | 5 |
Offside Rear fog lamp not working |1.3.2b| | 5 |
Parking brake lever has no reserve travel |3.1.6b| | 5 |
Brakes imbalanced across an axle | 5 |
Parking brake: efficiency below requirements (3.7.B.7) | 5 |
Horn not working |1.6.2a| | 4 |
Horn not working (1.6.2a) | 4 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 3 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 3 |
Rear brake binding | 3 |
Brake load sensing valve seized but ABS functioning (1.1.17 (c) (i)) | 2 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Nearside Side repeater incorrect colour |1.4.A.2f| | 2 |
Stop lamp remains on when the brakes are released | 2 |
Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
Rear brake disc in such a condition that it is seriously weakened | 2 |
Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
Nearside Front position lamp(s) not working (1.1.A.3b) | 2 |
Exhaust emissions exceed level of metered smoke for a turbo charged engine |8.2.2.2 |b|| | 2 |
Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
Brake hose excessively deteriorated | 2 |
Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Headlamp insecure (4.1.1 (c)) | 1 |
Offside Headlamp aim not tested (4.1.2 (b)) | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Brake cable insecure (1.1.15 (c)) | 1 |
Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Seat belt anchorage loose seat belt stalk fixing loose (7.1.1 (b)) | 1 |
Nearside Front Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Offside Front Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Offside Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Centre Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` Dream catcher and flowers. |8.3.1e| | 1 |
Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Nearside Passenger`s seat insecure |6.2.A.1| | 1 |
Nearside Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
Offside Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
Offside Side repeater insecure |1.4.A.2b| | 1 |
Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Rear Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Steering box has a significant oil leak |2.2.D.2e| | 1 |
Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Exhaust has a major leak of exhaust gases downpipe corroded. (6.1.2 (a)) | 1 |
Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
Offside Front Anti-roll bar pin or bush likely to become detached D bush bracket missing |5.3.4 |a| |ii|| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Offside Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Obligatory mirror missing (3.3 (a)) | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Obligatory mirror missing |8.1.1| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Nearside Front Drag link end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Offside Front Power steering pipe|s| or hose|s| excessively corroded |2.3.2| | 1 |
Nearside Lower Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Emissions not tested |7.0| | 1 |
Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Side repeater not working |1.4.A.2c| | 1 |
Brake load sensing valve inoperative |3.6.E.3| | 1 |
Fuel pipe leaking |7.2.3| | 1 |
Brake load sensing valve linkage obviously incorrectly adjusted |3.6.E.3| | 1 |
Nearside Front Statutory seat belt missing |5.1.1| | 1 |
Offside Front Statutory seat belt missing |5.1.1| | 1 |
Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Centre Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Stop lamp not working |1.2.1b| | 1 |
Nearside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Outer Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
front brake juddering severely |3.7.A.2b| | 1 |
Nearside Other passenger door catch insecure sliding door (6.2.3 (c) (ii)) | 1 |
Windscreen washer not working | 1 |
Anti-lock braking system warning lamp indicates an ABS fault | 1 |
Nearside Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting (6.1.6 (i) (i)) | 1 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
Nearside Front Body component corroded and likely to cause injury |6.2.1 |a| |i|| | 1 |
Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength front mount |5.3.6 |a| |i|| | 1 |
Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Offside Side repeater incorrect colour (4.4.3 (a)) | 1 |
Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Offside Front Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Service brake: efficiency below requirements |3.7.C.1a| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Offside Headlamp not in good working order |not working| |1.2.4a| | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Front Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Offside Front Position lamp not working |4.2.1 |a|| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Brake cable damaged excessively corroded/frayed (1.1.15 (a)) | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
Front brake application uneven | 1 |
front brakes release unevenly |3.7.B.4| | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting yellow chalk (6.2.2 (d) (i)) | 1 |
Offside Rear Direction indicator adversely affected by the operation of another lamp (1.4.A.2h) | 1 |
Offside Rear fog lamp not working (1.3.2b) | 1 |
Brake load sensing valve linkage defective and function impaired (3.6.E.3) | 1 |
Nearside Rear Leaf spring saddle is moving relative to the spring (2.4.B.7a) | 1 |
Offside Rear Leaf spring saddle is moving relative to the spring (2.4.B.7a) | 1 |
Front Windscreen wiper not operating automatically when switched on both (8.2.1b) | 1 |
Offside Front front brake binding (3.7.B.1) | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a) | 1 |
Nearside Front Front wheel bearing rough when rotated (2.5.A.2) | 1 |
Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
Nearside Front Shock absorbers has a serious fluid leak | 1 |
Nearside Front Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
Offside Front Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Power steering pipe/hose leaking leaking from joint on steering rack (2.1.5 (a)) | 1 |
Power steering pump leaking (2.1.5 (a)) | 1 |
Central Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength bump stop (5.3.6 (a) (i)) | 1 |
Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced step (7.1.1 (a) (i)) | 1 |
Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement (2.4.G.2) | 1 |
Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement (2.4.G.2) | 1 |
Offside Ball joint has excessive play (2.2.B.1f) | 1 |
Nearside Suspension arm has excessive play in a ball joint (2.4.G.2) | 1 |
Nearside Stop lamp not working (1.2.1b) | 1 |
Nearside Rear brake disc contaminated by oil (3.5.1h) | 1 |
Offside Rear brake disc contaminated by oil (3.5.1h) | 1 |
Rear Vehicle structure has excessive corrosion which adversely affects braking or steering (6.1.A.1) | 1 |
Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering (6.1.A.1) | 1 |
Horn not working (7.7 (a) (ii)) | 1 |
Service brake: efficiency below requirements (3.7.B.7) | 1 |
Electrical wiring insecure |1.9.2a| | 1 |
Offside Rear Leaf spring damaged and permanently distorted |2.4.B.1a| | 1 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Bonnet primary retaining device insecure corroded to the extent the bonnet is not secure (3.1 (c)) | 1 |
Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Offside Front Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced step (6.1.1 (c) (i)) | 1 |
Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced cross member behind step (6.1.1 (c) (i)) | 1 |
Front brake disc in such a condition that it is seriously weakened | 1 |
Offside Rear Brake disc contaminated diff seal excessively leaking (1.1.14 (b)) | 1 |
Offside Rear Brake pipe leaking on a hydraulic braking system to flexi leaking / corroded (1.1.11 (b) (ii)) | 1 |
Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced in front of rear wheel (6.1.1 (c) (i)) | 1 |
Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength above center on spring (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength above center of rear spring (5.3.6 (a) (i)) | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Nearside Rear Outline marker lamp not working |4.2.1 |a|| | 1 |
Offside Headlamp not working on dipped beam blown fuse (4.1.1 (a) (ii)) | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
Nearside Front Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Nearside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |