| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 17 |
| Headlamp aim out of alignment | 14 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 10 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 9 |
| Rear parking brake recording little or no effort | 9 |
| Offside Rear fog lamp not working |1.3.2b| | 8 |
| Registration plate lamp issues | 8 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Offside Headlamp not working on main beam |1.7.5a| | 4 |
| Brake pipe excessively corroded | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Rear brake binding | 3 |
| Front brake application uneven | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Brakes imbalanced across an axle | 3 |
| Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Battery insecure |1.9.1| | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Offside Headlamp insecure |1.7.3| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Nearside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front Headlamps matched pair are incorrectly positioned |1.7.3| | 1 |
| Nearside Front Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| All position lamps not working |4.2.1 |a|| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting damaged and its strength is seriously reduced |2.4.G.1| | 1 |
| Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Statutory seat belt missing |5.1.1| | 1 |
| Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Power steering malfunctioning fan belts loose (2.1.5 (a)) | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Window in an unacceptable condition door glass damaged (dangerous) (3.2 (c) (i)) | 1 |
| Offside Obligatory mirror does not provide a view to the rear (3.3 (c)) | 1 |
| Offside Rear Shock absorber detached |2.7.2b| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Indicator switch inoperative (4.4.2 (a) (ii)) | 1 |
| Rear fog lamp switch not operating in accordance with the requirements (4.5.3 (a)) | 1 |
| Nearside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Front Direction indicator not working right hand front inop |1.4.A.2c| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush left front |2.4.G.2| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Nearside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Offside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Rear brake application uneven | 1 |
| Nearside Rear Brake hose twisted |3.6.B.4c| | 1 |
| Offside Rear Brake hose twisted |3.6.B.4c| | 1 |
| Offside Front Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Windscreen has damage | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative |1.1.17 |c| |ii|| | 1 |
| Drag link end ball joint has excessive play front joint |2.2.B.1f| | 1 |
| Drag link end ball joint has excessive play rear joint |2.2.B.1f| | 1 |
| Nearside Front Brake pipe inadequately clipped under bonnet |3.6.B.1| | 1 |
| Exhaust system not adequately supported tail pipe insecure and leaking at silencer |7.1.1| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings body mount in nearside front wheelarch |6.1.B.2| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Nearside Front Axle king pin is loose in the axle beam |2.5.A.3a| | 1 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Offside Rear Leaf spring fractured (5.3.1 (b) (i)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Battery insecure and likely to fall from carrier wires near battery insecure as well (4.13 (a) (ii)) | 1 |
| Nearside Front Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Brake load sensing valve linkage defective and function impaired broken (1.1.17 (a)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Nearside Rear Lower Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Lower Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Nearside Front Lower Outline marker lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Rear Upper Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Lower Position lamp missing |4.2.1 |a|| | 1 |
| Front Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Rear Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Front Upper Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Rear fog lamp tell-tale not working |4.9.1 |a| |ii|| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |