Most common failures | No# failures |
---|
Headlamp aim out of alignment | 17 |
Brakes imbalanced across an axle | 13 |
Windscreen wiper does not clear the windscreen effectively | 13 |
Service brake: efficiency below requirements |3.7.B.7| | 9 |
Parking brake: efficiency below requirements |3.7.B.7| | 7 |
Registration plate lamp issues | 7 |
Horn not working |1.6.2a| | 7 |
Offside Stop lamp not working |1.2.1b| | 6 |
Nearside Stop lamp not working |1.2.1b| | 5 |
Offside Headlamp not working on dipped beam |1.7.5a| | 5 |
Rear parking brake recording little or no effort | 5 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 4 |
Brake load sensing valve linkage seized |3.6.E.3| | 4 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Rear brake application uneven | 3 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 3 |
Offside Rear fog lamp not working |1.3.2b| | 3 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 3 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
Brake hose excessively deteriorated | 2 |
Brake pipe excessively corroded | 2 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
Nearside Front Side repeater not working |1.4.A.2c| | 2 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Exhaust system not adequately supported |7.1.1| | 2 |
Hazard warning switch faulty |1.4.B.1d| | 2 |
Front Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Hazard warning lamps inoperative |1.4.B.1b| | 2 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner and outer sill [corroded at rear of door and previous repairs carried out will sealer] |6.1.1 |c| |i|| | 2 |
Offside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill corroded at rear of door [behind body panel] |6.1.1 |c| |i|| | 2 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Offside Side repeater not working |1.4.A.2c| | 2 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
Brake pedal spongy |3.3.B.1b| | 2 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Rear fog lamp missing |1.3.2a| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
Nearside Front Service brake indicates brake bind |3.7.D.2a| | 1 |
Nearside Front Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front brake disc excessively scored |3.5.1h| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Indicator tell tale inoperative |1.4.A.2a| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Front front brake binding |3.7.B.1| | 1 |
Rear front brake binding |3.7.B.1| | 1 |
Front brake application uneven | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Stop lamp not working both |1.2.1b| | 1 |
Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
Front Drag link end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Nearside Rear Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Nearside Front Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Front Exhaust system not adequately supported |7.1.1| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
Nearside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
Offside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Registration plate issues | 1 |
rear brake recording little or no effort |3.7.B.5a| | 1 |
Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Offside Front Power steering pump leaking from a failed component |2.3.3b| | 1 |
Nearside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Brake warning device indicates a leak in the brake system |3.3.E.3| | 1 |
Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced repairs to inner sills done using unsatisfactory method of repair [fibre glass used not welded] |6.1.1 |c| |i|| | 1 |
Offside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner wheel arch/wing corroded |6.1.1 |c| |i|| | 1 |
Nearside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner wheel arch/wing |6.1.1 |c| |i|| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Passenger`s seat insecure |6.2.A.1| | 1 |
Front position lamp|s| not working both |1.1.A.3b| | 1 |
Nearside Direction indicator not working + offside |1.4.A.2c| | 1 |
Direction indicator adversely affected by the operation of another lamp affecting n/s foglight |1.4.A.2h| | 1 |
Offside Front Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings step |6.1.B.2| | 1 |
Rear Body has a sharp edge caused by damage bumper |6.1.C.1| | 1 |
Offside Front Upper Suspension arm has excessive play in a ball joint + lower balljoint |2.4.G.2| | 1 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Nearside Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Offside Rear Braking system leaking |3.6.A.1| | 1 |
Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Front Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
Rear brake binding | 1 |
Nearside Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Headlamp aim beam image kick up to the offside |1.8| | 1 |
Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Headlamp not in good working order |not working| |1.2.4a| | 1 |
Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
An item not tested |Manual| | 1 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Nearside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
All position lamps not working |1.1.A.3b| | 1 |
Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Front Position lamp not working |4.2.1 |a|| | 1 |
Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
Brake performance not tested |1.2.1 |g|| | 1 |
Emissions not tested |8.2.2.2 |e|| | 1 |
Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Bonnet retaining device ineffective |8.4.2| | 1 |
Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Nearside Rear Stop lamp(s) missing NSR light unit missing (4.3.1 (a) (ii)) | 1 |
Nearside Front Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
Fuel hose leaking Under bonnet (6.1.3 (b) (i)) | 1 |
Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
Nearside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
Rear Bumper insecure (6.1.4 (a) (i)) | 1 |
Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Marked in yellow (6.2.2 (d) (i)) | 1 |
Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Marked in yellow (6.2.2 (d) (i)) | 1 |
Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Under bonnet (6.2.2 (d) (i)) | 1 |
Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Under bonnet (6.2.2 (d) (i)) | 1 |
Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
Exhaust has a major leak of exhaust gases silencer failed |7.1.2| | 1 |
Offside Rear reflector missing |1.5.1a| | 1 |
Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Nearside Front front parking brake recording little or no effort |3.7.B.6a| | 1 |
Nearside Front front brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear front brake recording little or no effort |3.7.B.5a| | 1 |
Steering box leaking to the extent that oil is dripping |2.1.1 |e| |ii|| | 1 |