| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 25 |
| Registration plate issues | 10 |
| Brake pipe excessively corroded | 8 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Registration plate lamp issues | 5 |
| Brake hose excessively deteriorated | 4 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 4 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front coil spring fractured |2.4.C.1a| | 2 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Brakes imbalanced across an axle | 2 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Nearside Front coil spring broken |2.4.C.1a| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Side repeater not working In mirror (4.4.1 (a) (ii)) | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt rearmost arm,balljoint situated in hub carrier |5.3.4 |b| |ii|| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Rear Sub-frame corroded and seriously weakened Holed on offside near front mount band stabilizer rod (5.3.3 (b) (i)) | 1 |
| Front Prop shaft securing bolt loose (6.1.7 (a) (i)) | 1 |
| Nearside Rear Sub-frame corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Rear Fuel pipe leaking |7.2.3| | 1 |
| Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Exhaust has a major leak of exhaust gases centre/rear (6.1.2 (a)) | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Front Suspension arm ball joint excessively worn rear arm |5.3.4 |a| |i|| | 1 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Inner Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Front Headlamp has a product on the light source so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn d bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn d bush (5.3.4 (a) (i)) | 1 |
| Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Wheel bearing so rough it is likely to overheat or break up (5.1.3 (b) (ii)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Side repeater insecure |1.4.A.2b| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded subframe |2.4.A.3| | 1 |
| Anti-roll bar linkage cracked |2.4.G.1| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Offside Rear Exhaust system not adequately supported o/s/r bracket |7.1.1| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn front arm (5.3.4 (a) (i)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Rear Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Front coil spring cracked |2.4.C.1a| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases back box |6.1.2 |a|| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Front Macpherson strut modified and seriously weakened |2.4.A.2| | 1 |
| Offside Front Macpherson strut modified and seriously weakened |2.4.A.2| | 1 |
| Offside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Suspension arm ball joint excessively worn castor control arm ball joint (5.3.4 (a) (i)) | 1 |
| Offside Front Brake pipe connection leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Offside Rear Upper Sub-frame corroded and seriously weakened area holed marked in yellow (5.3.3 (b) (i)) | 1 |
| Position lamp not working nearside front (4.2.1 (a) (ii)) | 1 |
| Suspension arm ball joint excessively worn nearside front camber arm (5.3.4 (a) (i)) | 1 |
| Suspension arm ball joint excessively worn offside front camber arm (5.3.4 (a) (i)) | 1 |
| Suspension arm pin or bush excessively worn nearside front camber arm mounting bush (5.3.4 (a) (i)) | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Rear Subframe mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected (5.3.6 (a) (ii)) | 1 |
| Offside Rear Subframe mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected (5.3.6 (a) (ii)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm ball joint excessively worn front most (5.3.4 (a) (i)) | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect blurred needs polishing (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect blurred needs polishing (4.1.2 (c)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Electronic stability control warning lamp indicates a fault |7.12 |e|| | 1 |
| Position lamp not working both fronts |4.2.1 |a|| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |