| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 13 |
| Offside Rear fog lamp not working |1.3.2b| | 9 |
| Service brake: efficiency below requirements |3.7.B.7| | 9 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Registration plate lamp issues | 8 |
| Brake pipe excessively corroded | 8 |
| Rear brake binding | 7 |
| Nearside front brake binding |3.7.B.1| | 5 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 5 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 5 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Brake hose excessively deteriorated | 5 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Horn not working |1.6.2a| | 3 |
| Registration plate issues | 3 |
| Brakes imbalanced across an axle | 3 |
| Rear brake application uneven | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Offside Front coil spring incomplete |2.4.C.1a| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 2 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Inner Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front Body or chassis is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front Steering arm deformed and unserviceable |2.2.C.1d| | 1 |
| Offside Front Steering arm deformed and unserviceable |2.2.C.1d| | 1 |
| front brake juddering severely |3.7.A.2b| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Brake valve insecurely mounted |3.6.A.2a| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Outer Fuel pipe leaking |7.2.3| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Brake valve leaking |3.6.A.1| | 1 |
| Offside Rear Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Offside rear brake recording little or no effort (3.7.B.5a) | 1 |
| Rear fog lamp switch faulty (1.3.1a) | 1 |
| Nearside Engine mounting damaged or deteriorated resulting in excessive movement (6.1.8 (a) (i)) | 1 |
| Nearside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Nearside Rear Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Offside Front Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Windscreen has damage | 1 |
| Vehicle Identification Number not permanently displayed |6.3.5.a| | 1 |
| Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Brake hose has insufficient room to move | 1 |
| Offside Rear Brake load sensing valve seized |3.6.E.3| | 1 |
| Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Towbar component insecure |6.6.1| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Offside Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear brake disc excessively scored |3.5.1h| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Seat belt anchorage prescribed area is deliberately modified which significantly reduces the original strength |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is deliberately modified which significantly reduces the original strength |5.2.6| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Offside front brake juddering severely |3.7.A.2b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear Suspension component mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |