| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 7 |
| Offside Headlamp aim not tested |1.8.A.1c| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Registration plate lamp issues | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Windscreen washer not working | 2 |
| Hazard warning switch insecure |1.4.B.1d| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Horn not working |1.6.2a| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Nearside Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Offside Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Nearside Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside An item not tested |Manual| | 1 |
| Windscreen wiper does not clear the windscreen effectively | 1 |
| Offside Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
| Offside Rear Leaf spring shackle pin retaining device insecurely fitted |2.4.B.3b| | 1 |
| Exhaust emissions exceed level of metered smoke for a non-turbo charged engine (8.2.2.2 (b)) | 1 |
| Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Rear All position lamps adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Position lamp adversely affected by the operation of another lamp number plate light is effected (4.2.3 (c)) | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing is corroded and holed (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing is corroded and holed (5.3.6 (a) (i)) | 1 |
| Brakes imbalanced across an axle | 1 |