Most common failures | No# failures |
---|
Headlamp aim out of alignment | 18 |
Windscreen wiper does not clear the windscreen effectively | 13 |
Horn not working |1.6.2a| | 9 |
Registration plate lamp issues | 8 |
Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
Brake pipe excessively corroded | 7 |
Service brake: efficiency below requirements |3.7.B.7| | 6 |
Brakes imbalanced across an axle | 6 |
Parking brake: efficiency below requirements |3.7.B.7| | 5 |
Offside Rear fog lamp not working |1.3.2b| | 4 |
Windscreen washer not working | 4 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 4 |
Offside Headlamp not working on main beam |1.7.5a| | 3 |
Rear parking brake recording little or no effort | 3 |
Horn not working |7.7 |a| |ii|| | 3 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
Brake load sensing valve linkage seized |3.6.E.3| | 3 |
Nearside Headlamp not working on main beam |1.7.5a| | 3 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 3 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 3 |
Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 3 |
Rear brake application uneven | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Fuel system component leaking |7.2.3| | 2 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 2 |
Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Brake hose excessively deteriorated | 2 |
Nearside Stop lamp not working |1.2.1b| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Offside Side repeater not working |1.4.A.2c| | 2 |
Rear fog lamp tell tale not working |1.3.1b| | 2 |
Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Rear Exhaust system not adequately supported |7.1.1| | 2 |
Registration plate issues | 2 |
Headlamp not working on dipped beam |1.7.5a| | 2 |
Power steering inoperative |2.3.3a| | 2 |
Indicator tell tale inoperative |1.4.A.2a| | 2 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 2 |
Bonnet cannot be secured in the closed position |8.4.1| | 2 |
Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 2 |
Horn not working (7.7 (a)) | 2 |
Stop lamp|s| not working All |4.3.1 |a| |ii|| | 1 |
Nearside Rear Anti-roll bar linkage insecurely attached |5.3.3 |a| |i|| | 1 |
Offside Rear Anti-roll bar linkage insecurely attached |5.3.3 |a| |i|| | 1 |
Exhaust has a major leak of exhaust gases Centre Box |6.1.2 |a|| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Windscreen wiper control is inaccessible to the driver |8.2.1a| | 1 |
Fuel cap/sealing device missing |7.2.4a| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Nearside Seat belt retracting mechanism defective |5.2.5b| | 1 |
Offside Seat belt retracting mechanism defective |5.2.5b| | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Nearside Side repeater missing |1.4.A.2b| | 1 |
Offside Side repeater missing |1.4.A.2b| | 1 |
Nearside Front Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Offside Rear Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Offside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Headlamp reflector seriously defective |4.1.1 |b| |ii|| | 1 |
Stop lamp|s| remains on when the brakes are released |4.3.2 |a| |iii|| | 1 |
Service brake excessively binding all brake wheels |1.2.1 |f|| | 1 |
Nearside Front Statutory seat belt of the wrong type. |5.1.1| | 1 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Rear Brake load sensing valve seized |3.6.E.3| | 1 |
Offside Front Brake hose leaking |3.6.A.1| | 1 |
Offside Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Nearside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Brake hose has insufficient room to move | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Brake load sensing valve seized |3.6.E.3| | 1 |
Nearside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Offside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
Nearside Rear Braking system leaking |3.6.A.1| | 1 |
Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Brake pedal does not operate a brake fitted to each wheel |3.3.A.3| | 1 |
Nearside Front Statutory seat belt missing |5.1.1| | 1 |
Offside Front Statutory seat belt missing |5.1.1| | 1 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
Offside Rear Position lamp not working |4.2.1 |a| |ii|| | 1 |
Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Rear Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill to outrigger holed |6.2.2 |d| |i|| | 1 |
Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting bulkhead / inner wing holed |6.2.2 |d| |i|| | 1 |
Offside Rear fog lamp missing |1.3.2a| | 1 |
Headlamp aim so that beam "kick up" is not visible on the screen both |4.1.2 |a|| | 1 |
Offside Front Upper Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Offside Front Lower Obligatory mirror seriously damaged, affecting the rear view mirror lens missing |8.1.2a| | 1 |
Rear Exhaust system not adequately supported mount tie melted with heat. |7.1.1| | 1 |
Exhaust system not adequately supported front mount broken |7.1.1| | 1 |
Nearside Front Direction indicator has less than 50% of the light sources illuminating faded when on hazards |poor output/brightness| |1.4.A.2c| | 1 |
All direction indicators not working |4.4.1 |a| |ii|| | 1 |
Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
Brake master cylinder/servo mounting prescribed area is inadequately repaired |1.1.21 |e| |i|| | 1 |
Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Outer Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Windscreen has a combination of minor damage areas which restrict the drivers view |8.3.1c| | 1 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front brake caliper leaking |3.6.A.1| | 1 |
Exhaust has a part missing |7.1.1a| | 1 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.2| | 1 |
Fuel tank leaking |7.2.3| | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Offside Rear Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
Service brake efficiency less than 50% of the required value |1.2.2 |a| |ii|| | 1 |
Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
Hazard warning lamps not flashing in phase, with ignition on all hazards working and then not working |1.4.B.1f| | 1 |
Hazard warning lamps not flashing in phase, with ignition off all hazards working and then not working |1.4.B.1f| | 1 |
Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Front position lamp|s| not working both |1.1.A.3b| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Front Side repeater not working |1.4.A.2c| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Offside Front Side repeater not working |1.4.A.2c| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear reflector missing |1.5.1a| | 1 |
Offside Rear reflector missing |1.5.1a| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front brake caliper leaking |3.6.A.1| | 1 |
Offside Front brake disc contaminated by brake fluid |3.5.1h| | 1 |
Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Fuel system component leaking excessively or a risk of fire (6.1.3 (b) (ii)) | 1 |
Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
Nearside Side repeater lens defective such that the emitted light is adversely affected (4.4.1 (b) (ii)) | 1 |
Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
Nearside Front Hazard warning lamps inoperative not flashing (4.4.1 (e)) | 1 |
Nearside Rear Hazard warning lamps inoperative not flashing (4.4.1 (e)) | 1 |
Offside Front Hazard warning lamps inoperative not flashing (4.4.1 (e)) | 1 |
Offside Rear Hazard warning lamps inoperative not flashing (4.4.1 (e)) | 1 |
Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Offside Headlamp aim not tested (4.1.2 (b)) | 1 |
Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Nearside Windscreen wiper not working (3.4 (a)) | 1 |
Offside Windscreen wiper not working (3.4 (a)) | 1 |
Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
Exhaust system insecure rear mount missing (6.1.2 (a)) | 1 |
Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
Offside Front Suspension spring mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected door step/rear leaf spring mount (5.3.6 (a) (ii)) | 1 |
Front Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i)) | 1 |
Offside Front Body mounting fixings insecure lower b pillar /body mounting (6.2.2 (c) (i)) | 1 |
Offside Front Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
Nearside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting step (6.2.2 (d) (i)) | 1 |
Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner arch (6.2.2 (d) (i)) | 1 |
Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Horn not working (7.7 (a) (ii)) | 1 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Main beam tell-tale missing (4.9.1 (a) (ii)) | 1 |
Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
Offside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
Offside Front Anti-roll bar pin or bush excessively worn Bracket loose (5.3.4 (a) (i)) | 1 |
Offside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
Offside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
Offside Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
Nearside Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
Nearside Rear Direction indicator lens defective such that the emitted light is adversely affected (4.4.1 (b) (ii)) | 1 |
Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength spring front mounting (5.3.6 (a) (i)) | 1 |
Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |