| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 18 |
| Registration plate lamp issues | 10 |
| Brake pipe excessively corroded | 9 |
| Brake hose excessively deteriorated | 8 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
| Registration plate issues | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 3 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 2 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Offside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Front Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Windscreen has damage | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Brake hose damaged | 2 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 2 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 2 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Front brake application uneven | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Outer Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Outer Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Outer Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Centre Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Outer Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Centre Front Steering damper leaking oil |2.2.C.1f| | 1 |
| Front Power steering ram|s| leaking from a failed component |2.3.3b| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Front Anti-roll bar pin or bush excessively worn n/s and o/s as chalked |5.3.4 |a| |i|| | 1 |
| Nearside Front Brake hose excessively damaged |1.1.12 |b| |ii|| | 1 |
| Offside Front Brake hose excessively damaged |1.1.12 |b| |ii|| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced floor pan as chalked |7.1.1 |a| |i|| | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced floor pan as chalked |7.1.1 |a| |i|| | 1 |
| Offside Rear Lower Seat belt anchorage prescribed area strength or continuity significantly reduced inner wheel arch as chalked |7.1.1 |a| |i|| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Front Power steering component|s| leaking |2.3.3b| | 1 |
| Rear brake application uneven | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Fuel pipe leaking |7.2.3| | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Rear Drive shaft which forms part of the suspension coupling gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Rear Coil spring not correctly located |2.4.C.2| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Front Steering damper leaking oil |2.2.C.1f| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Outer Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Outer Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength on sill (5.3.6 (a) (i)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Rear Exhaust system insecure corroded boot floor (6.1.2 (a)) | 1 |
| Nearside Rear Upper Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength as chalked (5.3.6 (a) (i)) | 1 |
| Offside Front Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Steering box has excessive free play detected at the steering wheel (steering box fitted) steering joint (2.3 (a) (i)) | 1 |
| Offside Front Lower Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i)) | 1 |
| Nearside Front Brake prescribed area is excessively corroded abs pump bracket (1.1.21 (e) (i)) | 1 |
| Offside Front Bumper likely to become detached hole on mounting point (6.1.4 (a) (ii)) | 1 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Front Brake hose damaged and likely to fail (1.1.12 (a)) | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |