Most common failures | No# failures |
---|
Headlamp aim out of alignment | 37 |
Windscreen wiper does not clear the windscreen effectively | 33 |
Registration plate lamp issues | 31 |
Brakes imbalanced across an axle | 20 |
Parking brake: efficiency below requirements |3.7.B.7| | 17 |
Brake pipe excessively corroded | 14 |
Service brake: efficiency below requirements |3.7.B.7| | 12 |
Rear brake application uneven | 11 |
Rear parking brake recording little or no effort | 11 |
Offside Headlamp not working on main beam |1.7.5a| | 11 |
Brake hose excessively deteriorated | 10 |
Offside Stop lamp not working |1.2.1b| | 7 |
Registration plate issues | 6 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 6 |
Nearside Headlamp not working on main beam |1.7.5a| | 6 |
Direction indicators not working |1.4.A.2c| | 6 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 6 |
Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Nearside Stop lamp not working |1.2.1b| | 5 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Horn not working |1.6.2a| | 5 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 4 |
Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
Fuel system component leaking |7.2.3| | 4 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 4 |
Stop lamp not working |1.2.1b| | 4 |
Rear Brake hose bulging under pressure |3.6.B.3| | 4 |
Front brake application uneven | 4 |
Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 4 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 4 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
Exhaust mounting missing |7.1.1b| | 3 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
Front passenger seat insecure |6.2.3| | 3 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 3 |
Indicator tell tale inoperative |1.4.A.2a| | 3 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
Nearside Front Brake hose bulging under pressure |3.6.B.3| | 3 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 3 |
Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
Offside Side repeater not working |1.4.A.2c| | 3 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Mechanical brake component has restricted free movement | 3 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 2 |
Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Parking brake lever has no reserve travel |3.1.6b| | 2 |
Nearside Rear Stop lamp not working |1.2.1b| | 2 |
Hazard warning switch faulty |1.4.B.1d| | 2 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 2 |
Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Exhaust emits clearly visible black smoke during acceleration |7.4.A2| | 2 |
Brake load sensing valve linkage seized |3.6.E.3| | 2 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Braking system leaking |3.6.A.1| | 2 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Front Headlamp aim not tested |1.8.A.1c| | 2 |
Offside Front Brake hose bulging under pressure |3.6.B.3| | 2 |
Stop lamp remains on when the brakes are released | 2 |
Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Front Headlamp not working on main beam |1.7.5a| | 2 |
Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 2 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
Headlamp switch faulty |1.7.1| | 2 |
Nearside Side repeater not working |1.4.A.2c| | 2 |
Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 2 |
Bonnet cannot be secured in the closed position |8.4.1| | 2 |
Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Hazard warning lamps inoperative |1.4.B.1b| | 2 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 2 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 2 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Exhaust system not adequately supported |7.1.1| | 2 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Offside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 2 |
Offside Rear Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Offside Obligatory mirror insecure |8.1.1| | 1 |
Offside Rear All position lamps not working |1.1.A.3b| | 1 |
Steering system excessively tight |2.2.D.1| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Offside Rear Brake pipe excessively damaged |3.6.B.2c| | 1 |
Nearside Front Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
Offside Front Axle swivel joint has excessive movement between a swivel joint and its housing |2.5.A.1b| | 1 |
Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear Stop lamp missing |1.2.1a| | 1 |
Nearside Front Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
Nearside Front Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Front Horn not working |1.6.2a| | 1 |
Nearside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Offside Front Side repeater not working |1.4.A.2c| | 1 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outrigger by spring mounting |6.1.B.2| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outrigger by spring mounting |6.1.B.2| | 1 |
Central Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings o/s outrigger by spring mounting |6.1.B.2| | 1 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front Brake pipe leaking |3.6.A.1| | 1 |
Bonnet retaining device ineffective |8.4.2| | 1 |
Fuel hose leaking tank |7.2.3| | 1 |
Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Offside Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Steering damper damaged and unserviceable |2.2.C.1d| | 1 |
Nearside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Seat belt anchorage prescribed area is fractured |5.2.6| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Offside Front Steering rack has excessive free play detected at the steering wheel |steering rack fitted| |2.3 |a| |i|| | 1 |
Nearside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Jacking point |6.1.B.2| | 1 |
Offside Front Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings Jacking point |6.1.B.2| | 1 |
Rear Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
Rear Rear fog lamp not working |1.3.2b| | 1 |
Rear reflector not red in colour |1.5.1d| | 1 |
Windscreen washer control is inaccessible to the driver |8.2.1a| | 1 |
Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 1 |
Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
All position lamps not working |1.1.A.3b| | 1 |
Nearside Rear Rear reflector not red in colour |1.5.1d| | 1 |
Offside Rear Rear reflector not red in colour |1.5.1d| | 1 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
Offside Front Seat belt anchorage prescribed area is deliberately modified which significantly reduces the original strength |5.2.6| | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Fuel hose insecure from tank |7.2.1| | 1 |
Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Brake pedal anti-slip provision loose |3.3.A.1b| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Passenger`s seat insecure |6.2.A.1| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded Outrigger / valance area rear of spring |2.4.A.3| | 1 |
Front Body has a sharp edge caused by corrosion NS + OS door + bonnet |6.1.C.1| | 1 |
Nearside Rear Body has a sharp edge caused by corrosion sill + valence front and rear of NSR wheel |6.1.C.1| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill |6.1.B.2| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Steering column top bearing excessively worn |2.1.2c| | 1 |
Nearside Front Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
Central Lower Electrical wiring insecure wires hanging from underside centre of vehicle |1.9.2a| | 1 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Seat belt affected by a damaged seat frame |5.2.1b| | 1 |
Offside Front Seat belt affected by a damaged seat frame |5.2.1b| | 1 |
Rear position lamp|s| obviously incorrectly positioned |1.1.A.3a| | 1 |
Offside Front Brake hose stretched |3.6.B.4c| | 1 |
Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
Nearside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Centre Front Exhaust mounting missing |7.1.1b| | 1 |
Nearside Rear brake drum contaminated by oil |3.5.1h| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Inner Front Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
Front Passenger`s seat insecure |6.2.A.1| | 1 |
Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Headlamp aim beam image kick up to the offside |1.8| | 1 |
Fuel tank leaking |7.2.3| | 1 |
Nearside Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
Offside Front brake disc excessively pitted |3.5.1h| | 1 |
Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Offside Front Brake hose leaking |3.6.A.1| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front Shock absorber insecure |2.7.2b| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Rear reflector missing |1.5.1a| | 1 |
Offside Rear Statutory seat belt missing |5.1.1| | 1 |
Nearside Rear Direction indicator incomplete |1.5.A1b| | 1 |
Nearside Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Centre Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Outer Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Towbar component insecure |6.6.1| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Obligatory mirror insecure |8.1.1| | 1 |
Nearside Rear Body has a projection caused by damage |6.1.C.1| | 1 |
Brake cable has restricted free movement |3.5.1k| | 1 |
Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Nearside All position lamps not working |1.1.A.3b| | 1 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
Nearside Front Driver`s seat insecure |6.2.A.1| | 1 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Front position lamp|s| not working |1.1.A.3b| | 1 |
Power steering pump leaking from a failed component |2.3.3b| | 1 |
Windscreen washer control missing |8.2.1a| | 1 |
Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Emissions not tested |7.0| | 1 |
Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Offside Front Headlamp insecure |1.7.3| | 1 |
Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
Nearside Front Braking system leaking |3.6.A.1| | 1 |
Nearside Front brake disc contaminated by brake fluid |3.5.1h| | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Brake vacuum build up too slow |3.3.E.6| | 1 |
Rear brake binding | 1 |
Nearside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
Offside Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Windscreen has damage | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |