| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 47 |
| Registration plate lamp issues | 22 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Brakes imbalanced across an axle | 4 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Outline marker lamp not working |4.2.1 |a|| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Rear Parking |secondary brake| on a single line braking system has no recorded effort at a wheel no effort whatsoever |1.3.1 |a| |ii|| | 1 |
| Nearside Rear Parking |secondary brake| on a single line braking system has inadequate effort at a wheel only 7% brake efficiency achieved |1.3.1 |a| |i|| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear brake binding | 1 |
| Nearside Rear Seat belt flexible stalk damaged likely to lead to failure under load |5.2.4a| | 1 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Upper Stop lamp not working |1.2.1b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear fog lamp has less than 50% of the light sources illuminating |1.3.2b| | 1 |
| Rear Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Windscreen washer not working | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear brake application uneven | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn D bush |5.3.4 |a| |i|| | 1 |
| Nearside Rear Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Front brake application uneven | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Front Steering rack has excessive free play detected at the steering wheel (steering rack fitted) track arm (2.3 (a) (i)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Rear Upper Direction indicator not working (1.4.A.2c) | 1 |
| Offside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Side repeater light intensity significantly reduced / obscured (4.4.3 (a)) | 1 |
| Nearside Body panel damaged and likely to cause injury repeater lens (6.2.1 (a) (i)) | 1 |
| Nearside Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Obligatory mirror insecure (3.3 (b) (ii)) | 1 |
| Nearside Front Inner Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Front Body panel corroded and likely to cause injury Nearside and Offside and doors (6.2.1 (a) (i)) | 1 |
| Body component damaged and likely to cause injury Nearside and Offside, wing mirror covers, sharp (6.2.1 (a) (i)) | 1 |
| Nearside Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Front Outline marker lamp missing (4.2.1 (a) (ii)) | 1 |
| Offside Front Outline marker lamp missing (4.2.1 (a) (ii)) | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Offside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Drivers step (6.1.1 (c) (i)) | 1 |