| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 17 |
| Parking brake: efficiency below requirements |3.7.B.7| | 9 |
| Registration plate lamp issues | 7 |
| Service brake: efficiency below requirements |3.7.B.7| | 6 |
| Brakes imbalanced across an axle | 6 |
| Rear parking brake recording little or no effort | 5 |
| Rear brake application uneven | 5 |
| Brake pipe excessively corroded | 4 |
| Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 3 |
| Rear Exhaust system not adequately supported |7.1.1| | 3 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Brake hose excessively deteriorated | 3 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Front Drag link end ball joint has excessive play |2.2.B.1f| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Horn not working |1.6.2a| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Rear brake binding | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Front Brake pipe inadequately clipped |3.6.B.1| | 2 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Offside Inner Rear Seat belt retracting mechanism defective |5.1.B.6b| | 2 |
| Nearside Outer Rear Seat belt retracting mechanism defective |5.1.B.6b| | 2 |
| Nearside Inner Rear Seat belt retracting mechanism defective |5.1.B.6b| | 2 |
| Nearside Body panel damaged and likely to cause injury (6.2.1 (a) (i)) | 1 |
| Offside Front Upper Position lamp missing (4.2.1 (a) (ii)) | 1 |
| Offside Rear Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i)) | 1 |
| Nearside Rear Body panel insecure Before rear axle (6.2.1 (a) (i)) | 1 |
| Nearside Upper Position lamp not working Both rear and front (4.2.1 (a) (ii)) | 1 |
| Offside Front Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Front Exhaust emissions likely to be affected by an exhaust leak Down pipe from exhaust brake (8.2.2.1 (b)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Drag link end ball joint has excessive play Non fixed lateral play (2.1.3 (b) (i)) | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Cross member rotten in wheel arch (6.1.1 (c) (i)) | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| rear brake grabbing severely |3.7.A.5b| | 1 |
| Nearside Front Outer Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Statutory seat belt missing |5.1.1| | 1 |
| Exhaust has part of the system excessively deteriorated |6.3.1a| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.5 |b| |i|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Centre Rear Upper Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Rear Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front An item not tested |Manual| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Seat belt insecurely fixed to the seat |5.1.B.2a| | 1 |
| Offside Inner Passenger`s seat security significantly reduced |6.5.14| | 1 |
| Nearside Passenger`s seat security significantly reduced |6.5.14| | 1 |
| Offside Outer Passenger`s seat security significantly reduced |6.5.14| | 1 |
| Driving control|s| functionally incomplete |6.8.1a| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Rear reflector not red in colour |1.5.1d| | 1 |
| Nearside Rear position lamp|s| not working upper and lower |1.1.A.3b| | 1 |
| Nearside Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering both |2.5.A.3a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Steering lock stop incorrectly adjusted |2.2.D.2c| | 1 |
| Offside Front Steering lock stop incorrectly adjusted |2.2.D.2c| | 1 |
| Offside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Driver`s door cannot be opened from outside the vehicle Secured by restraining device |6.2.B.1b| | 1 |
| Offside Rear Brake pipe leaking Pipe union loose |3.6.A.1| | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Power steering pump insecure |2.3.6| | 1 |
| Front Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Rear Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
| Windscreen wiper blade insecure | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside front brake juddering severely |3.7.A.2b| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Rear Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Centre Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Statutory seat belt missing |5.1.1| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Steering system fouling |2.2.D.2a| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Driving control|s| clutch pedal anti-slip provision worn smooth. |6.8.3| | 1 |
| Nearside Rear Passenger`s seat security significantly reduced |6.5.14| | 1 |
| Offside Outer Rear Seat belt retracting mechanism defective |5.1.B.6b| | 1 |
| Nearside Inner Rear Seat belt cut causing the fibres to separate |5.1.B.3a| | 1 |
| Nearside Inner Rear Seat belt insecurely fixed to the seat |5.1.B.2a| | 1 |
| Nearside Outer Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Inner Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Upper Rear outline marker lamp|s| not working |1.1.B.1c| | 1 |
| Steering box has a significant oil leak |2.2.D.2e| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |