| Most common failures | No# failures |
|---|
| Brakes imbalanced across an axle | 17 |
| Registration plate lamp issues | 9 |
| Headlamp aim out of alignment | 6 |
| Horn not working |1.6.2a| | 5 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Brake pipe excessively corroded | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Front brake application uneven | 3 |
| Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 2 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 2 |
| Stop lamp remains on when the brakes are released | 2 |
| Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Front passenger seat insecure |6.2.3| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Steering arm deformed and unserviceable |2.2.C.1d| | 1 |
| Steering system fouling |2.2.D.2a| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside rear brake grabbing severely |3.7.A.5b| | 1 |
| Offside Rear brake drum in such a condition that it is seriously weakened |3.5.1i| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Front Position lamp not working both (4.2.1 (a) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Windscreen wiper not working both (3.4 (a)) | 1 |
| Steering column top bearing excessively worn (2.2.2 (b)) | 1 |
| Rear Drag link end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Upper Leaf spring shackle pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Leaf spring shackle pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Exhaust system insecure silencer (6.1.2 (a)) | 1 |
| Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Windscreen wiper not working very slow operation (3.4 (a)) | 1 |
| Offside Rear Outer Vehicle structure is fractured and structural rigidity is significantly reduced sharp edges (6.1.1 (a) (i)) | 1 |
| Nearside Rear Outer Vehicle structure is fractured and structural rigidity is significantly reduced sharp edges (6.1.1 (a) (i)) | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Both front inner arches have holes caused by corrosion |6.1.B.2| | 1 |
| Nearside Front Electrical wiring insecure |1.9.2a| | 1 |
| Rear Electrical wiring insecure |1.9.2a| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Rear Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Nearside Front Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear brake application uneven | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Rear reflector defective or damaged by more than 50% of the reflecting surface |4.8.1 |a| |ii|| | 1 |
| Nearside Seat belt not functioning as intended buckle inoperative |7.1.2 |c|| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Rear fog lamp light intensity significantly reduced |4.5.4 |a|| | 1 |
| Rear fog lamp does not emit a steady red light |4.5.4 |a|| | 1 |
| Trailer electrical socket |13 pin| not operating the trailer lamps as intended |4.10 |c| |i|| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Nearside Seat belt not functioning as intended |7.1.2 |c|| | 1 |
| Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Towbar retaining device missing |6.6.3a| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Offside front brake grabbing severely |3.7.A.2b| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Seat belt adjustment fitting badly deteriorated |5.2.3| | 1 |
| Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front Side repeater incomplete |1.5.A1b| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Brake hose excessively deteriorated | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear Lower Rear fog lamp not working |1.3.2b| | 1 |
| Offside Inner Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Centre Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
| Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |