| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 11 |
| Brakes imbalanced across an axle | 11 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Registration plate lamp issues | 9 |
| Nearside Side repeater not working |1.4.A.2c| | 7 |
| Rear parking brake recording little or no effort | 5 |
| Offside Side repeater not working |1.4.A.2c| | 5 |
| Registration plate issues | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Rear brake application uneven | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Hazard warning switch insecure |1.4.B.1d| | 3 |
| Brake pipe excessively corroded | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 2 |
| Front Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 2 |
| Horn not working (7.7 (a)) | 2 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Hazard warning switch faulty |1.4.B.1d| | 2 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 2 |
| Horn not working |1.6.2a| | 2 |
| Fuel tank leaking |7.2.3| | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Front Leaf spring fractured |2.4.B.1a| | 1 |
| Centre Front passenger seat insecure |6.2.3| | 1 |
| Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.3 |a|| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
| Nearside Windscreen wiper missing |3.4 |a|| | 1 |
| Offside Windscreen wiper missing |3.4 |a|| | 1 |
| Nearside Rear Body component corroded and likely to cause injury |6.2.1 |a| |i|| | 1 |
| Rear Body component corroded and likely to cause injury |6.2.1 |a| |i|| | 1 |
| Nearside Seat belt anchorage loose |7.1.1 |b|| | 1 |
| Passenger`s seat with a defective structure |6.2.6 |a| |i|| | 1 |
| Nearside Service brake lagging in operation |1.2.1 |d|| | 1 |
| Brake master cylinder leaking |1.1.10 |b| |ii|| | 1 |
| Rear Brake pipe at imminent risk of failure or fracture |1.1.11 |a|| | 1 |
| Nearside Rear Brake pipe at imminent risk of failure or fracture |1.1.11 |a|| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Front Brake hose porous |1.1.12 |e|| | 1 |
| Nearside Front Brake hose porous |1.1.12 |e|| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Front Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
| Offside Front Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Rear brake binding | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Offside Front Lower Leaf spring has excessive side play at eye |shackle| |2.4.B.4| | 1 |
| Front passenger seat insecure |6.2.3| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Indicator switch missing |1.4.A.1| | 1 |
| Nearside Direction indicator not working |1.4.A.2c| | 1 |
| Offside Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Stop lamp has a product on the light source so it is not visible from a reasonable distance |1.2.1d| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside front brake grabbing severely |3.7.A.2b| | 1 |
| Nearside Front Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Rear Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Front Fuel system component leaking (6.1.3 (b) (i)) | 1 |
| Offside Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Front Fuel hose leaking near no2 injector (6.1.3 (b) (i)) | 1 |
| Offside Front Inner Brake master cylinder/servo mounting prescribed area is excessively corroded arch (1.1.21 (e) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Body has a sharp edge caused by corrosion bonnet |6.1.C.1| | 1 |
| Body has a sharp edge caused by corrosion offside lower panels |6.1.C.1| | 1 |
| Offside Front Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt forward drag link end |2.2.C.1c| | 1 |
| Offside Front Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt rearward drag link end |2.2.C.1c| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Emissions not tested |8.2.2.2 |e|| | 1 |
| Nearside Rear Service brake lagging in operation |1.2.1 |d|| | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Front Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Inner Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |
| Offside Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |
| Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Hazard warning switch insecure |1.5.4a| | 1 |
| Exhaust has a major leak of exhaust gases |6.3.2a| | 1 |
| Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Parking brake lever, pawl mechanism pivot|s| retaining device insecure |3.1.4b| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Upper Rear position lamp|s| missing |1.1.A.3a| | 1 |
| Nearside Upper Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Upper Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded Inner Wheel arch- AS PER MARKED |2.4.A.3| | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Fuel system component leaking (6.1.3 (b) (i)) | 1 |
| Offside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Brake master cylinder leaking Master Cylinder wet below reservoir (1.1.10 (b) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Offside Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Brake performance unable to be tested due to fluid leak on nearside rear brake (1.2.1 (g)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Rear Brake load sensing valve linkage defective and function impaired (1.1.17 (a)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Prop shaft securing bolt loose Front end of prop (6.1.7 (a) (i)) | 1 |
| Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Direction indicator incorrect colour broken lens showing white light |1.4.A.2f| | 1 |
| Bonnet retaining device ineffective |8.4.2| | 1 |
| Fuel pipe leaking no3 injector area - leak off pipe |7.2.3| | 1 |
| Nearside Front Lower Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Rear Lower Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Side repeater flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Electrical wiring insecure |1.9.2a| | 1 |
| Electrical wiring inadequately supported |1.9.2a| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Rear fog lamp switch insecure |1.3.1a| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` sun visor |8.3.1e| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |