| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 7 |
| Headlamp aim out of alignment | 6 |
| Registration plate lamp issues | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Registration plate issues | 2 |
| Rear parking brake recording little or no effort | 2 |
| Brake hose excessively deteriorated | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Rear position lamp|s| incomplete |1.1.4a| | 2 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting below drivers seat |6.2.2 |d| |i|| | 1 |
| Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced rear of cab/floor |6.1.1 |c| |i|| | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced step/sill welding incomplete |6.1.1 |c| |i|| | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill |6.1.1 |c| |i|| | 1 |
| Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill/step |6.1.1 |c| |i|| | 1 |
| Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced crossmember below rear of cab |6.1.1 |c| |i|| | 1 |
| Central Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting crossmember at either side of propshaft mount |6.2.2 |d| |i|| | 1 |
| Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced crossmember at handbrake mechanism |6.1.1 |c| |i|| | 1 |
| Nearside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced centre of chassis leg at crossmember |6.1.1 |c| |i|| | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis leg |6.1.1 |c| |i|| | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis leg |6.1.1 |c| |i|| | 1 |
| Nearside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Offside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Centre Brake cable knotted |3.5.1b| | 1 |
| Offside Brake pipe inadequately supported |3.6.B.1| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.5 |b| |i|| | 1 |
| Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Windscreen wiper missing |3.4 |a|| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear brake application uneven | 1 |
| Nearside Front passenger door hinge insecure lower hinge |6.2.3 |c| |ii|| | 1 |
| Nearside Outline marker lamp not working |4.2.1 |a|| | 1 |
| Rear brake binding | 1 |
| Nearside Rear Outline marker lamp not working |4.2.1 |a|| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside front brake juddering severely |3.7.A.2b| | 1 |
| Nearside Front front brake juddering severely |3.7.A.2b| | 1 |
| Nearside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Offside Outline marker lamp not working |4.2.1 |a|| | 1 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Body has a projection caused by damage |6.1.C.1| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Leaf spring fractured |2.4.B.1a| | 1 |
| Offside Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Inner Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Outer Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Inner Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Centre Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |