Most common failures | No# failures |
---|
Headlamp aim out of alignment | 260 |
Registration plate lamp issues | 134 |
Brake pipe excessively corroded | 122 |
Windscreen wiper does not clear the windscreen effectively | 78 |
Parking brake: efficiency below requirements |3.7.B.7| | 72 |
Offside Rear fog lamp not working |1.3.2b| | 45 |
Rear parking brake recording little or no effort | 44 |
Rear brake binding | 43 |
Rear brake application uneven | 38 |
Service brake: efficiency below requirements |3.7.B.7| | 38 |
Brakes imbalanced across an axle | 34 |
Registration plate issues | 30 |
Parking brake lever has no reserve travel |3.1.6b| | 25 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 24 |
Horn not working |1.6.2a| | 24 |
Exhaust has a major leak of exhaust gases |7.1.2| | 23 |
Offside Front position lamp|s| not working |1.1.A.3b| | 18 |
Offside Stop lamp not working |1.2.1b| | 18 |
Brake load sensing valve linkage seized |3.6.E.3| | 17 |
Nearside Stop lamp not working |1.2.1b| | 16 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 15 |
Offside Front brake disc excessively pitted |3.5.1h| | 14 |
Rear Rear fog lamp not working |1.3.2b| | 14 |
Offside Side repeater not working |1.4.A.2c| | 14 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 13 |
Brake hose excessively deteriorated | 13 |
Offside Rear Rear fog lamp not working |1.3.2b| | 13 |
Front brake disc in such a condition that it is seriously weakened | 13 |
Indicator tell tale inoperative |1.4.A.2a| | 13 |
Nearside Side repeater not working |1.4.A.2c| | 12 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 12 |
Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 12 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 12 |
Nearside Front brake disc excessively pitted |3.5.1h| | 11 |
Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 11 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 11 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 11 |
Offside rear brake recording little or no effort |3.7.B.5a| | 10 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 10 |
Nearside Rear Stop lamp not working |1.2.1b| | 10 |
Windscreen has damage | 10 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 10 |
Indicator switch faulty |1.4.A.1| | 10 |
Driver`s seat insecure |6.2.A.1| | 10 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 10 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 10 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 9 |
Rear Exhaust has a part missing |7.1.1a| | 9 |
Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 9 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 9 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 9 |
Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 9 |
Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 9 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 9 |
Rear fog lamp not working |1.3.2b| | 9 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 9 |
Emissions not tested |7.0| | 9 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 9 |
Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 8 |
Rear fog lamp tell tale not working |1.3.1b| | 8 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 8 |
Rear Exhaust system not adequately supported |7.1.1| | 7 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 7 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 7 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 7 |
Offside Rear Stop lamp not working |1.2.1b| | 7 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 7 |
Anti-lock braking system warning lamp indicates an ABS fault | 7 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 6 |
Exhaust system not adequately supported |7.1.1| | 6 |
Offside Rear Leaf spring fractured |2.4.B.1a| | 6 |
Offside Headlamp not working on dipped beam |1.7.5a| | 6 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 6 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 6 |
Rear Mechanical brake component has restricted free movement | 6 |
Front brake application uneven | 6 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
Offside Side repeater incomplete |1.5.A1b| | 6 |
Front brake disc excessively pitted |3.5.1h| | 6 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 5 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 5 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 5 |
Nearside Front Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 5 |
Brake pedal spongy |3.3.B.1b| | 5 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 5 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 5 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 5 |
Offside Rear fog lamp missing |1.3.2a| | 5 |
Fuel system component leaking |7.2.3| | 5 |
Nearside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 5 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 5 |
Offside Front Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 5 |
Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 5 |
Centre Exhaust system not adequately supported |7.1.1| | 5 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 5 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 5 |
Nearside Headlamp not working on main beam |1.7.5a| | 5 |
Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 5 |
Nearside Seat belt retracting mechanism defective |5.2.5b| | 5 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
Nearside Front Direction indicator not working |1.4.A.2c| | 5 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 4 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 4 |
Windscreen wiper blade insecure | 4 |
Nearside Direction indicator not working |1.4.A.2c| | 4 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 4 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 4 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 4 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 4 |
Nearside Side repeater missing |1.4.A.2b| | 4 |
Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 4 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 4 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 4 |
Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
Exhaust has a part missing |7.1.1a| | 4 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 4 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 4 |
Offside Rear fog lamp insecure |1.3.2a| | 4 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 4 |
Steering system excessively tight |2.2.D.1| | 4 |
Front passenger seat insecure |6.2.3| | 4 |
Nearside Front Statutory seat belt missing |5.1.1| | 4 |
Nearside Front Side repeater not working |1.4.A.2c| | 4 |
Nearside Front Side repeater incomplete |1.5.A1b| | 4 |
Offside Front Direction indicator incorrect colour |1.4.A.2f| | 4 |
Offside Rear position lamp|s| incomplete |1.1.4a| | 4 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 4 |
Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 4 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Nearside Side repeater incomplete |1.5.A1b| | 3 |
Nearside Statutory seat belt missing |5.1.1| | 3 |
Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 3 |
Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 3 |
Nearside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Offside Front Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 3 |
Offside Headlamp aim not tested |1.8.A.1c| | 3 |
Rear Exhaust mounting missing |7.1.1b| | 3 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 3 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Front Drag link end ball joint has excessive play |2.2.B.1f| | 3 |
Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Front Front position lamp|s| not working |1.1.A.3b| | 3 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
Offside Front Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 3 |
Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 3 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
Nearside Side repeater incorrect colour |1.4.A.2f| | 3 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 3 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
Offside Front Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 3 |
Front Body has a sharp edge caused by damage |6.1.C.1| | 3 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 3 |
Fuel hose leaking |7.2.3| | 3 |
Offside Front Headlamp not working on main beam |1.7.5a| | 3 |
Nearside Indicator tell tale inoperative |1.4.A.2a| | 3 |
Offside Obligatory mirror insecure |8.1.1| | 3 |
Brake hose has insufficient room to move | 3 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 3 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
rear brakes release unevenly |3.7.B.4| | 3 |
Nearside Front All position lamps not working |1.1.A.3b| | 3 |
Offside Headlamp aim beam image too far to the right |1.6.B4| | 3 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Service brake: efficiency below requirements |3.7.D.4| | 2 |
Parking brake: efficiency below requirements |3.7.D.4| | 2 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
Front Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 2 |
Offside Front Side repeater not working |1.4.A.2c| | 2 |
Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
Front Exhaust system not adequately supported |7.1.1| | 2 |
Offside Front Brake hose bulging under pressure |3.6.B.3| | 2 |
Nearside Body has a projection caused by damage |6.1.C.1| | 2 |
Offside Side repeater missing |1.4.A.2b| | 2 |
Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
Power steering pipe|s| or hose|s| leaking |2.3.3b| | 2 |
Rear Stop lamp not working |1.2.1b| | 2 |
Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
Rear fog lamp switch faulty |1.3.1a| | 2 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Bonnet cannot be secured in the closed position |3.1 |b| |i|| | 2 |
Nearside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 2 |
Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 2 |
Offside Rear wheel cylinder leaking |3.6.A.1| | 2 |
Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Front Leaf spring eye defective |anchor| |2.4.B.1b| | 2 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
Nearside Rear Rear position lamp|s| incomplete |1.1.4a| | 2 |
Offside Indicator tell tale inoperative |1.4.A.2a| | 2 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
An item not tested |Manual| | 2 |
Nearside Front Direction indicators not working |1.4.A.2c| | 2 |
Offside Front Direction indicator not working |1.4.A.2c| | 2 |
Nearside Obligatory mirror is incapable of being adjusted to provide an adequate view to the rear |8.1.2b| | 2 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 2 |
Nearside Front Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 2 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 2 |
Nearside Obligatory mirror missing |8.1.1| | 2 |
Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 2 |
Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 2 |
Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
Exhaust mounting missing |7.1.1b| | 2 |
Nearside Rear Leaf spring fractured |2.4.B.1a| | 2 |
Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Nearside Rear An item not tested |Manual| | 2 |
Offside Rear Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 2 |
Centre Statutory seat belt missing |5.1.1| | 2 |
Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 2 |
Fuel tank leaking |7.2.3| | 2 |
Bonnet cannot be secured in the closed position |8.4.1| | 2 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 2 |
Brake hose damaged | 2 |
Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Nearside Body has a projection caused by corrosion |6.1.C.1| | 2 |
Rear Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
Brake load sensing valve linkage obviously incorrectly adjusted |3.6.E.3| | 2 |
Front Fuel pipe leaking |7.2.3| | 2 |
Nearside Windscreen wiper blade missing |8.2.2| | 2 |
Offside Rear Direction indicator not working |1.4.A.2c| | 2 |
Offside Rear fog lamp not visible from a reasonable distance |1.1.6b| | 2 |
Brake valve insecurely mounted |3.6.A.2a| | 2 |
Offside Front Leaf spring fractured |2.4.B.1a| | 2 |
Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 2 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.1.B.7| | 2 |
Nearside Front Obligatory mirror insecure |8.1.1| | 2 |
Offside Front Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 2 |
Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 2 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 2 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
Offside Rear Leaf spring cracked |2.4.B.1a| | 2 |
Headlamp switch faulty |1.7.1| | 2 |
Body has a sharp edge caused by damage |6.1.C.1| | 2 |
Offside Side repeater incorrect colour |1.4.A.2f| | 2 |
Offside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Upper Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Rear An item not tested |Manual| | 2 |
Nearside Rear reflector missing |1.5.1a| | 2 |
Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
Nearside Side repeater insecure |1.4.A.2b| | 2 |
Offside Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
Offside Side repeater not working (4.4.1 (a) (ii)) | 2 |
Offside Front Steering component mounting prescribed area is excessively corroded (2.1.2 (e) (i)) | 2 |
Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 2 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |