| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 18 |
| Registration plate lamp issues | 17 |
| Brake pipe excessively corroded | 17 |
| Windscreen wiper does not clear the windscreen effectively | 14 |
| Offside Stop lamp not working |1.2.1b| | 9 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 5 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Rear Exhaust system not adequately supported |7.1.1| | 5 |
| Registration plate issues | 4 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 4 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Horn not working |1.6.2a| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Front coil spring cracked |2.4.C.1a| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Outer Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Nearside Front coil spring fractured |2.4.C.1a| | 2 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front coil spring incomplete |2.4.C.1a| | 2 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 2 |
| Offside Front coil spring cracked |2.4.C.1a| | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Power steering pipe|s| or hose|s| excessively corroded |2.3.2| | 1 |
| Offside Rear Outer Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Central Rear Seat belt missing catch (7.1.2 (a)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Offside Brake pipe leaking |3.6.A.1| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Inner Steering component mounting prescribed area is excessively corroded WING |2.2.C.1h| | 1 |
| Nearside Front Inner Suspension component mounting prescribed area is excessively corroded WING |2.4.A.3| | 1 |
| Offside Front Inner Suspension component mounting prescribed area is excessively corroded WING |2.4.A.3| | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area is excessively corroded SILL |2.4.A.3| | 1 |
| Brakes imbalanced across an axle | 1 |
| Headlamp cleaning device inoperative |1.7.2| | 1 |
| Nearside Front Anti-roll bar linkage rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Upper Suspension spring mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected (5.3.6 (a) (ii)) | 1 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Front Fuel system component leaking |7.2.3| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp flickers when tapped lightly by hand |1.2.4c| | 1 |
| Offside Front Headlamps matched pair are not the same colour |1.7.6| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Centre Rear An item not tested |Manual| | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
| Offside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Rear Fluid leak harmful to the environment or a risk to other road users PIPE CORRODED (8.4.1 (a) (i)) | 1 |
| Central Prop shaft bearing excessively worn (6.1.7 (b) (i)) | 1 |
| Suspension arm ball joint excessively worn both front upper (5.3.4 (a) (i)) | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Inner Rear Drive shaft which forms part of the suspension coupling gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Nearside Front Anti-roll bar linkage attachment bracket/mounting likely to fail (5.3.3 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage attachment bracket/mounting likely to fail (5.3.3 (b) (ii)) | 1 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Front Inner Vehicle structure has excessive corrosion which adversely affects braking or steering wing (6.1.1 (c) (ii)) | 1 |
| Offside Rear Outer Vehicle structure has excessive corrosion which adversely affects braking or steering sill (6.1.1 (c) (ii)) | 1 |
| Offside Rear Inner Vehicle structure has excessive corrosion which adversely affects braking or steering sill (6.1.1 (c) (ii)) | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering floor (6.1.1 (c) (ii)) | 1 |
| Offside Rear Inner Vehicle structure has excessive corrosion which adversely affects braking or steering wing and boot (6.1.1 (c) (ii)) | 1 |
| Nearside Rear Inner Vehicle structure has excessive corrosion which adversely affects braking or steering wing and boot (6.1.1 (c) (ii)) | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting jacking point (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting jacking point (6.2.2 (d) (i)) | 1 |
| Offside Rear Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Outer Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Windscreen has damage | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Front Exhaust system insecure BACKBOX HAS A HOLE (6.1.2 (a)) | 1 |
| Nearside Rear Vehicle structure is deformed and structural rigidity is significantly reduced (6.1.1 (a) (i)) | 1 |
| Nearside Front Vehicle structure is deformed and structural rigidity is significantly reduced (6.1.1 (a) (i)) | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings wheel arch area |6.1.B.2| | 1 |
| Offside Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting bolt missing |2.4.G.1| | 1 |
| Nearside Front Seat belt anchorage prescribed area is fractured |5.2.6| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |