| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 35 |
| Brake pipe excessively corroded | 29 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 14 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 11 |
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Registration plate lamp issues | 8 |
| Registration plate issues | 8 |
| Parking brake lever has no reserve travel |3.1.6b| | 7 |
| Rear fog lamp tell tale not working |1.3.1b| | 7 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 6 |
| Anti-lock braking system warning lamp indicates an ABS fault | 5 |
| Rear parking brake recording little or no effort | 5 |
| Brakes imbalanced across an axle | 5 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 5 |
| Rear fog lamp switch faulty |1.3.1a| | 4 |
| Offside Front coil spring fractured |2.4.C.1a| | 4 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Battery insecure |1.9.1| | 4 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Emissions not tested |7.0| | 3 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 3 |
| Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 3 |
| Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 3 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Front brake disc in such a condition that it is seriously weakened | 3 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front coil spring fractured |2.4.C.1a| | 2 |
| Rear coil spring fractured |2.4.C.1a| | 2 |
| Front passenger seat cannot be secured in the upright position. |6.2.4| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front coil spring broken |2.4.C.1a| | 2 |
| Offside Obligatory mirror insecure |8.1.1| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Rear fog lamp tell-tale not working |4.9.1 |a| |ii|| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Windscreen has damage | 2 |
| Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Central Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Fuel pipe leaking |7.2.3| | 1 |
| Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Rear Shock absorbers likely to become detached (5.3.2 (a) (ii)) | 1 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 1 |
| Offside Inner Front Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Windscreen washer not working | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Centre Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Inner Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Rear Fuel system component leaking (6.1.3 (b) (i)) | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear fog lamp not working |1.3.2b| | 1 |
| Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Lower Anti-roll bar attachment bracket/mounting damaged and seriously weakened |5.3.3 |b| |i|| | 1 |
| Front brake application uneven | 1 |
| Offside Front Exhaust mounting missing |7.1.1b| | 1 |
| Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
| Centre Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Service brake excessively fluctuating both rears (1.2.1 (e)) | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Rear Upper Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Rear Shock absorber casing corroded externally so the unit does not function |2.7.2a| | 1 |
| Nearside Rear Suspension arm attachment bracket/mounting nut missing |2.4.G.1| | 1 |
| Offside Rear Suspension arm attachment bracket/mounting nut missing |2.4.G.1| | 1 |
| Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded floor |2.4.A.3| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded inner wheel arch |2.4.A.3| | 1 |
| Direction indicator incorrect colour both rear |1.4.A.2f| | 1 |
| Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Nearside Rear Upper Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Centre Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Centre Front Steering damper leaking oil |2.2.C.1f| | 1 |
| Offside Rear Wheel stud|s| missing |4.2.A.1e| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear Fluid suspension pipe leaking |2.4.D.2| | 1 |
| Rear Fuel pipe leaking |7.2.3| | 1 |
| Rear Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Offside Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Front Battery insecure |1.9.1| | 1 |
| Nearside Front Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner wheel arch (7.1.1 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner wheel arch (7.1.1 (a) (i)) | 1 |
| Nearside Rear Upper Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Front Steering damper leaking oil |2.2.C.1f| | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Front Exhaust has a part missing |7.1.1a| | 1 |
| Offside Brake pipe leaking on a hydraulic braking system Brake pipe under floor |1.1.11 |b| |ii|| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Nearside Outer Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Rear Brake valve leaking (1.1.7 (d) (i)) | 1 |
| Nearside Front Upper Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Front Lower Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Front coil spring cracked |2.4.C.1a| | 1 |