Most common failures | No# failures |
---|
Headlamp aim out of alignment | 19 |
Registration plate lamp issues | 16 |
Brakes imbalanced across an axle | 11 |
Brake pipe excessively corroded | 11 |
Rear brake application uneven | 10 |
Offside Rear fog lamp not working |1.3.2b| | 10 |
Service brake: efficiency below requirements |3.7.B.7| | 9 |
Parking brake: efficiency below requirements |3.7.B.7| | 9 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 9 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 9 |
Windscreen wiper does not clear the windscreen effectively | 8 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
Nearside Stop lamp not working |1.2.1b| | 6 |
Offside Stop lamp not working |1.2.1b| | 6 |
Horn not working |1.6.2a| | 6 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Rear parking brake recording little or no effort | 5 |
Rear brake binding | 4 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 4 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 4 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 4 |
Indicator tell tale inoperative |1.4.A.2a| | 3 |
Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
Direction indicators not working |1.4.A.2c| | 3 |
Brake hose excessively deteriorated | 3 |
Fuel system component leaking |7.2.3| | 3 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine (7.4.B.3b) | 3 |
Front brake application uneven | 3 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
Offside Side repeater not working |1.4.A.2c| | 3 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Hazard warning switch faulty |1.4.B.1d| | 2 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
Brake load sensing valve linkage seized |3.6.E.3| | 2 |
Nearside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
Bonnet cannot be secured in the closed position |8.4.1| | 2 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 2 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 2 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Rear fog lamp tell tale not working |1.3.1b| | 2 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Obligatory mirror insecure |8.1.1| | 2 |
Nearside Side repeater not working |1.4.A.2c| | 2 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Offside Rear fog lamp missing |1.3.2a| | 2 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
Offside Rear Direction indicator not working |1.4.A.2c| | 2 |
Offside Side repeater not working (1.4.A.2c) | 2 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Rear Exhaust has a part missing |7.1.1a| | 2 |
Front Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Rear Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
Windscreen has damage | 2 |
Bonnet retaining device excessively deteriorated |8.4.2| | 2 |
Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 2 |
Rear fog lamp not working |1.3.2b| | 2 |
rear brakes release unevenly |3.7.B.4| | 2 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Offside Front Lower Shock absorbers likely to become detached (5.3.2 (a) (ii)) | 1 |
Offside Front Suspension component mounting prescribed area fractured significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
Front Exhaust fumes entering cabin bad blow (6.1.2 (b) (i)) | 1 |
Fuel system component leaking pump? (6.1.3 (b) (i)) | 1 |
Offside Front Steering component mounting prescribed area is excessively corroded chassis (2.1.2 (e) (i)) | 1 |
Windscreen wiper not working |3.4 |a|| | 1 |
Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
Front Exhaust has a major leak of exhaust gases and crntre |6.1.2 |a|| | 1 |
Offside Front Direction indicators not working |1.4.A.2c| | 1 |
Nearside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Offside Front Brake hose stretched |found during steering lock to lock check| |2.2.D.2b| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Rear Direction indicator has a product on the light source so it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Brake master cylinder/servo mounting prescribed area is excessively corroded bulkhead |3.6.C.3| | 1 |
Nearside Front Body has a sharp edge caused by corrosion wing |6.1.C.1| | 1 |
Nearside Front Body has a sharp edge caused by corrosion door |6.1.C.1| | 1 |
Offside Front Steering component mounting prescribed area is excessively corroded chassis |2.2.C.1h| | 1 |
Nearside Windscreen wiper blade missing |8.2.2| | 1 |
Offside Windscreen wiper blade missing |8.2.2| | 1 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Bonnet retaining device ineffective |8.4.2| | 1 |
Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
Windscreen wiper control is inaccessible to the driver |8.2.1a| | 1 |
Front passenger seat insecure |6.2.3| | 1 |
Nearside Rear Rear fog lamp not working |1.3.2b| | 1 |
Nearside Body has a projection caused by damage |6.1.C.1| | 1 |
Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
Brake servo insecurely mounted |3.6.A.2a| | 1 |
Offside Side repeater excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Steering system excessively tight |2.2.D.1| | 1 |
Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
Offside Rear Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
Front Exhaust system not adequately supported |7.1.1| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Nearside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Sill inner and outer (6.1.1 (c) (i)) | 1 |
Offside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Sill inner and outer (6.1.1 (c) (i)) | 1 |
Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Close to shock absorber top mount (6.2.2 (d) (i)) | 1 |
Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
Offside Front Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Front brake disc in such a condition that it is seriously weakened | 1 |
Nearside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Headlamp aim not tested |1.8.A.1c| | 1 |
Nearside Front passenger seat insecure |6.2.3| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Nearside Front Lower Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Offside Front Lower Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Brake load sensing valve has been disconnected and was fitted as standard |3.6.E.2| | 1 |
Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Axle beam has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
Mechanical brake component has restricted free movement | 1 |
Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement (7.2.4b) | 1 |
Offside Rear fog lamp insecure (1.3.2a) | 1 |
Front Brake pipe inadequately clipped (3.6.B.1) | 1 |
Offside Front position lamp(s) not working (1.1.A.3b) | 1 |
Nearside Side repeater not working (1.4.A.2c) | 1 |
Nearside Headlamp insecure (1.7.3) | 1 |
Rear fog lamp emits a light other than red (1.3.2e) | 1 |
Rear fog lamp tell tale not working (1.3.1b) | 1 |
Nearside Front Side repeater excessively damaged so that it is not visible from a reasonable distance (1.4.A.2e) | 1 |
Offside Front Side repeater excessively damaged so that it is not visible from a reasonable distance (1.4.A.2e) | 1 |
Nearside Front Brake hose bulging under pressure (3.6.B.3) | 1 |
Fuel cap/sealing device does not fasten securely by positive means (7.2.4b) | 1 |
Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
All direction indicators not working (4.4.1 (a) (ii)) | 1 |
Windscreen washer not working | 1 |
Windscreen wiper not working (3.4 (a)) | 1 |
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Offside Headlamp aim not tested (4.1.2 (b)) | 1 |
Nearside Front Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength front (5.3.6 (a) (i)) | 1 |
Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength rear (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension spring mounting prescribed area fractured significantly reducing structural strength rear (5.3.6 (a) (i)) | 1 |
Body component corroded and likely to cause injury os door step (6.2.1 (a) (i)) | 1 |
Nearside Body component corroded and likely to cause injury door step (6.2.1 (a) (i)) | 1 |
Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt both link arm (2.1.3 (g) (ii)) | 1 |
Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
Offside Front Direction indicator not working (1.4.A.2c) | 1 |
Offside Headlamp aim beam image obviously incorrect (1.8.A.1b) | 1 |
Nearside Front Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Side repeater incomplete |1.5.A1b| | 1 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Front Exhaust mounting missing |7.1.1b| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
Nearside Rear Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
Offside Side repeater flashing less than 60 times a minute |1.4.A.2g| | 1 |
Brake fluid significantly below minimum mark (1.1.10 (d) (ii)) | 1 |
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Inner Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Inner Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Fuel pipe leaking |7.2.3| | 1 |
Offside Front Brake pipe kinked |3.6.B.2b| | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Outer Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Centre Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
Offside Front brake disc excessively pitted |3.5.1h| | 1 |
Front Fuel system component leaking |7.2.3| | 1 |
Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Rear Leaf spring fractured |2.4.B.1a| | 1 |
Registration plate issues | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Offside front brake juddering severely |3.7.A.2b| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Body has a sharp edge caused by corrosion x 2 places |6.1.C.1| | 1 |
Nearside Rear Brake pipe inadequately clipped axle pipe |3.6.B.1| | 1 |
Brake master cylinder/servo mounting prescribed area is excessively corroded underneath section |3.6.C.3| | 1 |
rear parking |secondary| brakes imbalanced | 1 |
Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Steering lock stop incorrectly adjusted |2.2.D.2c| | 1 |
Fuel tank leaking |7.2.3| | 1 |
Offside Body has a projection caused by damage |6.1.C.1| | 1 |
Offside Front Body has a sharp edge caused by corrosion wing |6.1.C.1| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Front Direction indicator incomplete |1.5.A1b| | 1 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Rear position lamp|s| insecure |1.1.A.3a| | 1 |
Offside Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Emissions not tested |7.0| | 1 |
Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Offside Rear front brake binding |3.7.B.1| | 1 |
Offside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Nearside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |