| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 19 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Registration plate lamp issues | 6 |
| Registration plate issues | 5 |
| Brake pipe excessively corroded | 5 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Horn not working |1.6.2a| | 4 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Direction indicators not working |1.4.A.2c| | 3 |
| Battery insecure |1.9.1| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Rear brake binding | 3 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
| Brakes imbalanced across an axle | 2 |
| Hazard warning lamps inoperative |1.4.B.1b| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Offside Steering locking device missing |2.2.C.1g| | 1 |
| Offside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Side repeater incomplete |1.5.A1b| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Inner Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Inner Rear Fuel tank leaking |7.2.3| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Rear Fuel hose leaking |7.2.3| | 1 |
| Nearside Front Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear fog lamp missing |4.5.1 |a| |ii|| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Front brake excessively fluctuating | 1 |
| Rear rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
| Trailer electrical socket damaged so that lead cannot be securely connected |1.9.3b| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Vehicle Identification Number not permanently displayed |6.3.5.a| | 1 |
| Fuel system component leaking rear undernmeath |7.2.3| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Vehicle Identification Number not displayed (0.2 (a)) | 1 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Inner Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension arm has excessive play in a pin/bush front bush |2.4.G.2| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded top mounting panel |2.4.A.3| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Shock absorbers has an excessively worn bush lower bush |5.3.2 |c|| | 1 |
| Nearside Rear Lower Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Nearside Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Fuel pipe leaking |7.2.3| | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Offside brake disc has restricted free movement |3.5.1j| | 1 |
| Front brake application uneven | 1 |
| Offside Front brake disc contaminated by oil |3.5.1h| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Centre Rear Statutory seat belt missing |5.1.1| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Nearside Front Front position lamp|s| not working sidelight |1.1.A.3b| | 1 |
| Offside Front Front suspension ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Lower Driver`s door hinge insecure |6.2.B.2| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |