| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 19 |
| Headlamp aim out of alignment | 18 |
| Parking brake: efficiency below requirements |3.7.B.7| | 11 |
| Registration plate lamp issues | 8 |
| Rear parking brake recording little or no effort | 8 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 7 |
| Brake hose excessively deteriorated | 7 |
| Registration plate issues | 6 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Nearside Stop lamp not working |1.2.1b| | 5 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 4 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 4 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Front coil spring fractured |2.4.C.1a| | 3 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 3 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 3 |
| Rear brake binding | 3 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Windscreen has damage | 2 |
| Rear Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front coil spring cracked |2.4.C.1a| | 2 |
| Offside Front Lower Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Nearside Inner Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Offside Inner Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front brake disc excessively scored |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Side repeater incorrect colour |1.4.A.2f| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Centre Rear Statutory seat belt missing |5.1.1| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Nearside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Side repeater insecure |1.4.A.2b| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Outer Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Outer Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Outer Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Outer Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Brake hose excessively damaged |3.6.B.4d| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Direction indicator not working |1.4.A.2c| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Front coil spring cracked |2.4.C.1a| | 1 |
| Nearside Rear Inner Vehicle structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired Around Sub frame mounting (6.2.2 (d) (ii)) | 1 |
| Offside Rear Inner Vehicle structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired Around Sub frame mounting (6.2.2 (d) (ii)) | 1 |
| Offside Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Sill holed (6.1.1 (c) (i)) | 1 |
| Nearside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Boot well/Sill area (6.1.1 (c) (i)) | 1 |
| Offside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Boot well/sill area (6.1.1 (c) (i)) | 1 |
| Nearside Front Anti-roll bar linkage cracked |2.4.G.1| | 1 |
| Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
| Offside Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Suspension component mounting prescribed area is excessively corroded offside rear wheel arch | rear bottom | |2.4.A.3| | 1 |
| Suspension component mounting prescribed area is excessively corroded nearside rear wheel arch | rear bottom | |2.4.A.3| | 1 |
| Suspension component mounting prescribed area is excessively corroded offside rear wheel arch | bottom front | |2.4.A.3| | 1 |
| Suspension component mounting prescribed area is excessively corroded nearside rear wheel arch | centre above shocker | |2.4.A.3| | 1 |
| Suspension component mounting prescribed area is excessively corroded nearside rear wheel arch | front bottom | |2.4.A.3| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings nearside rear floor |6.1.B.2| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings offside rear floor |6.1.B.2| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings offside centre inner sill |6.1.B.2| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings nearside front floor |6.1.B.2| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded x2 |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded x2 |2.4.A.3| | 1 |
| Side repeater missing |1.4.A.2b| | 1 |
| Nearside Inner Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Inner Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Windscreen wiper blade missing |8.2.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Inner Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Inner Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Inner Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Inner Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Steering locking device missing |2.2.C.1g| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Steering box leaking to the extent that oil is dripping (2.1.1 (e) (ii)) | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill back (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill back (5.3.6 (a) (i)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wing (5.3.6 (a) (i)) | 1 |
| Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wing (5.3.6 (a) (i)) | 1 |
| Front Lower Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Lower Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Lower Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Lower Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Lower Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Brakes imbalanced across an axle | 1 |
| Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Lower Trailing arm fractured |2.4.G.1| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Offside front brake juddering severely |3.7.A.2b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |