| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 7 |
| Headlamp aim out of alignment | 5 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 4 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 4 |
| Windscreen washer not working | 4 |
| Nearside Drag link end ball joint dust cover missing (2.1.3 (g) (ii)) | 4 |
| Offside Drag link end ball joint dust cover missing (2.1.3 (g) (ii)) | 4 |
| Brakes imbalanced across an axle | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Nearside Track rod end ball joint dust cover missing (2.1.3 (g) (ii)) | 3 |
| Offside Track rod end ball joint dust cover missing (2.1.3 (g) (ii)) | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Rear fog lamp tell-tale missing (4.9.1 (a) (ii)) | 2 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 2 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Rear fog lamp switch missing (4.5.3 (a)) | 2 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 2 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 2 |
| Rear fog lamp switch insecure |1.3.1a| | 2 |
| Rear fog lamp switch faulty |1.3.1a| | 2 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Horn not working (7.7 (a)) | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Emissions not tested |7.0| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| All direction indicators not working all (4.4.1 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Rear Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Brake load sensing valve linkage defective and function impaired (1.1.17 (a)) | 1 |
| Nearside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt front (2.1.3 (g) (ii)) | 1 |
| Nearside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt rear (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt front (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt rear (2.1.3 (g) (ii)) | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Registration plate issues | 1 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Rear Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Position lamp switch does not operate in accordance with the requirements (4.2.2 (a)) | 1 |
| Fuel system component leaking fuel filter (6.1.3 (b) (i)) | 1 |
| Track rod end ball joint dust cover missing all (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill. (7.1.1 (a) (i)) | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Offside Rear Suspension arm severely distorted |2.4.G.1| | 1 |
| Rear Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
| Nearside Rear Suspension arm severely distorted |2.4.G.1| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Power steering pump leaking from a failed seal |2.3.3b| | 1 |
| Offside Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Centre Steering damper leaking oil |2.2.C.1f| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Nearside Front Intermediate drop arm insecure |2.2.B.1a| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Fluid leak harmful to the environment or a risk to other road users fuel leak on engine (8.4.1 (a) (i)) | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Rear Fuel pipe insecure |7.2.1| | 1 |
| Speedometer clearly inoperative (7.8 (b) (ii)) | 1 |
| Steering linkage ball joint ball joint dust cover missing all steering ball joint covers missing (2.1.3 (g) (ii)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Service brake grabbing severely (1.2.1 (c)) | 1 |
| Offside Rear Service brake grabbing severely (1.2.1 (c)) | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Position lamp not working all (4.2.1 (a) (ii)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Track rod end ball joint dust cover missing (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover missing (2.1.3 (g) (ii)) | 1 |